Professional Documents
Culture Documents
41 Label and Move Chamfers
41 Label and Move Chamfers
41 Label and Move Chamfers
MT10043 – NX 9.0
1. Open syn3_label_chamfer.
The length of the angled face increases. This face is not recognized as a
chamfer and the typical chamfer offset distances are not maintained.
7. Press Esc or Cancel to exit the command without moving any faces.
If the construction faces are not highlighted, you can use select Select Face
1 and Select Face 2 options in the Construction Faces group to select each
face manually.
The length of the angled face is unchanged. This face is now recognized as a
chamfer and the offset distances are maintained.
Note If you see an active <OK> button in the dialog box, you can choose another
command without clicking the middle mouse button to complete the
current command.
3. In the Offsets group, from the Cross Section list, select Symmetric Offset.
The original angled faces were not symmetric in length and height. It would
have been difficult to make this change without using the Label
Chamfer and Resize Chamfercommands.
5. Close the part now or close all parts when you exit the session.