The document discusses submittal requirements and manufacturers for distribution switch gear and switch boards. It lists approved manufacturers for switchboards/panels and states that products equal in quality to those specified will be acceptable pending the engineer's decision. It also provides requirements for main low tension switch boards, stating they must be indoor, cellular type construction and assembled by one manufacturer in accordance with IEC 60439-1 standards.
The document discusses submittal requirements and manufacturers for distribution switch gear and switch boards. It lists approved manufacturers for switchboards/panels and states that products equal in quality to those specified will be acceptable pending the engineer's decision. It also provides requirements for main low tension switch boards, stating they must be indoor, cellular type construction and assembled by one manufacturer in accordance with IEC 60439-1 standards.
The document discusses submittal requirements and manufacturers for distribution switch gear and switch boards. It lists approved manufacturers for switchboards/panels and states that products equal in quality to those specified will be acceptable pending the engineer's decision. It also provides requirements for main low tension switch boards, stating they must be indoor, cellular type construction and assembled by one manufacturer in accordance with IEC 60439-1 standards.
A. Refer to Section 16010 - "Basic Electrical Requirements".
PART 2 - PRODUCTS
2.01 MANUFACTURERS
A. Subject to compliance with requirements, provide products by the following:
1. ABB Power Distribution - Italy/Europe 2. Mitsubishi - Japan 3. Moeller - Germany/Austria 4. Legrand - France/Italy 5. Merlin Gerin - France 6. Siemens - Germany
B. Approved Switchboard/Panel Manufacturers:
1. EBOMAC 2. Salem Al Nisf 3. Al Ahleia Switchgear 4. Al Diwan Switchgear 5. Dakeel Al Jaseer 6. General Control Group C. The products and manufacturers specified herein, are specified for the purpose of establishing minimum quality standards. Products equal in quality to, or better than those specified, will be acceptable. The decision of acceptability rests with the Engineer. 2.02 GENERAL A. Provide complete distribution equipment which shall comprise main low tension switch boards, main and sub main switch boards, distribution boards, isolators, switch fuses, etc. B. The supply and distribution arrangement shall be as indicated on the schematic diagrams Drawings. C. Provide all required signals for monitoring through BAS system according to specification Section 15976.
2.03 MAIN LOW TENSION SWITCH BOARDS
A. General 1. The main low tension switch boards shall be of Form 3b indoor construction cellular type, dead front, metal enclosed multi-cubicle type, free standing, dust and vermin protected, front operated and of clean and modern appearance. 2. The switch boards shall be assembled and coordinated by one manufacturer and shall be constructed in accordance with IEC 60439-1. Complying Form 3b construction.
Ministry of Health (MOH) III-2/16426-2 Distribution Switch Gear