Professional Documents
Culture Documents
Pac Unit - Installation
Pac Unit - Installation
Pac Unit - Installation
B
E T
INL
IR
E RA
NS
DE
C ON
RIGGING INSTRUCTIONS
ATTENTION TO RIGGERS
• Insert 2" nominal pipe through holes in the base rail as shown in the figure below for slings.
• Holes in base rail are centered around the unit center of gravity.
• Use wooden pallet or spreader bar when rigging, to prevent the slings from damaging the unit.
• Rollers may be used to move the unit on the roof or ground.
SPREADER BAR
PROPER CLEARANCE TO BE
PROVIDED
COMPRESSOR
END
MUST BE 2" NOMINAL PIPE THRU UNIT FOR SLINGS TO AVOID BASE DAMAGE
4
UNIT MOUNTING
ROOF
CONCRETE PAD
CONDENSATE DRAIN CONNECTION
• Use standard PVC pipe with NPT connection for the condensate drain. Provide a 'P' trap immediately at the condensate drain connection.
• Piping has to be sloped away from the unit.
• Remember to remove the drain hole plug before operating the unit. Avoid bends & elbows.
DUCT CONNECTION
The units can be connected to the ducting in horizontal configuration. Connect ducting using flexible duct connection. The duct should
be properly designed and the drive package should match the required CFM & corresponding external static pressure.
ATTENTION: Avoid abrupt changes in size and/or direction of duct to ensure proper unit performance.
ELECTRIC HEATERS
Electric heater kit is installed as an externally mounted kit at the supply air opening.
K H R G
CONDENSER SECTION
L M Y N
=
CONTROL COMPARTMENT
CONDENSATE DRAIN OUTLET
A\IR IN 3/4" NPT
POWER INLET
A\IR IN (OPTIONAL)
FRESH AIR OPENING/HOOD
CONDENSER COIL
AIR IN SUPPLY AIR RETURN AIR
TOP VIEW
F AIR OUT
K U H N
CONTROL BOX
ACCESS PANEL
COMPRESSOR
ACCESS PANEL
OPENING
ACCESS PANEL
C
FILTER
[9.17] DRAIN OUTLET
233
[5.67]
144
POWER INLET
D X X G D
G L
B B
A 16 x 25mm
MOUNTING SLOT (3EACH SIDE)
MOUNTING SLOT (4EACH SIDE-PY/PQ360)
SIDE VIEW FRONT VIEW SIDE VIEW
DIMENSIONS
MODEL
A B C D F G H K L N R S M U X
PY180 - PY210 2794(110) 1778(70) 1266(49.83)1715(67.52) 1737(68.37) 197(7.75) 817(32.17) 720(28.35) 1200(47.25) 83(3.27) 912(35.9) 666(26.22) 194(7.64) 171(6.73) -
PY240 - PY340 3048(120) 2196(86.44) 1446(56.94) 2135(84.1) 2152(84.72) 324(12.76) 915(36.02) 740(29.13) 1200(47.25) 84(3.31) 1050(41.34) 666(26.22) 289(11.38) 194(7.64) -
PY360 3683(145) 2184(86) 1446(56.94)2125(83.66) 2184(86) 42(1.65) 938(36.93) 527(20.75) - 97(3.83) 1000(39.37) 680(26.77) 254(10) 372(14.65) 1125(44.29)
NOTE:
1. All dimensions are in mm (dimensions in brackets are in inches).