Professional Documents
Culture Documents
The Center Tank Is Supposed To Be Emptied Before The Wing Tanks
The Center Tank Is Supposed To Be Emptied Before The Wing Tanks
True
False
2.- With the center tank pump mode SEL switch in AUTO; the center tank pumps:
Continue to run until five minutes after the center tank is empty.
3.- Fuel transfer from the outer compartment to the inner compartment of the wing
tanks occurs when the inner compartment quantity decreases to:
250 kilograms
450 kilograms
750 kilograms
5000 kilograms
4.- What indication will you see on the overhead fuel panel if the center tank has
more than 250 kilograms of fuel and the left or right wing tank have less than 5,000
kilograms.
Fuel imbalance.
6.- The fuel quantity indication on ECAM for the outer cell is boxed amber if:
Both transfer valves fail to open when inner cell is at low level.
7.- An amber line appears across the last two digits of the ECAM FOB indication
when:
True
False
9.- Which of the following would cause the fault light to illuminate on the MODE SEL
push button?
Center tank pumps do not stop 5 min after center tank low level reached.
10.- The message CTR TK FEEDG appears in the MEMO. What does this mean?
Outer cell of the wing tanks, inner cell of the wing tanks, and/or center tank.
Outer cell of the wing tanks, and inner cell of the wing tanks.
12.- Center tank pumps do not stop 5 min after center tank low level reached.
Yes, only on the refueling panel.
13.- During normal operations when should the fuel transfer valves open?
14.- What does an amber line across the last two digits of the fuel quantity mean?
A disagreement betwen fuel measured and fuel entered on the MCDU has been
detected.
Obtains fuel from the left fuel manifold via the left side fuel pumps or if needed, the APU
fuel pump.
Obtains fuel from the left fuel manifold via the right side fuel pumps.
16.- With fuel in the center tank the CTR TK MODE SEL push button selected to
AUTO and CTR TK PUMP push buttons ON (lights out), which of the following
conditions cause the center tank fuel pumps to stop?
Anytime the slats are extended or an overfill condition is detected in either wing inner cell
For a short test period after the first Engine Master Switch is selected "ON" when the
slats are extended.
17.- With fuel in the center tank, the CTR TK MODE SEL push button selected to
AUTO and the CTR TK PUMP push buttons ON (lights out), the center tank pumps:
Will operate for a short period after the first engine MASTER switch is selected ON and
while slats are retracted.
They will continue to run until the center tank is empty or slats are extended.
18.- After engine start, center tank fuel pumps run for ______ minutes regardless of
slat position.
1 minute.
2 minutes.
3 minutes.
5 minutes.
19.- The message OUTER TK FUEL XFRD appears in the MEMO. What does this
mean?
Manually controlled and open when the MODE SEL push button is selected to MAN.
Automatically close if a low level is sensed in either main wing tank, they automatically
close at the next fueling.
21.- Why do the center tank pups stop automatically when then slats are extended
for takeoff?
Dumping takeoff, the center tank fuel is pumped to the rear to trim aircraft
To ensure that the engines are fed from the wing tanks for takeoff (feeding segregation)
22.- What precaution should you observe when gravity feeding fuel?
Operate the aircraft below 15,000 feet.
23.- Refueling time at normal pump pressure is _____ minutes for the wing tanks
and _____ minutes for all tanks.
15 & 25.
17 & 20.
15 & 20.
25 & 35.
24.- After engine shutdown, what are your actions to close the fuel transfer valves?
No action is required. The valves will close automatically during the next refuelling.
In flight if the fuel X FEED push button is selected OPEN and center tank MODE SEL
push button is selected to MAN.
26.- How has the fuel been transferred from the outer to the inner tanks?
The transfer valve has been opened automatically by the low lever sensor in the center
tanks
The transfer valve has been opened automatically by the low level sensor in the inner
tank.
1,200 kg.
1,500 kg
2,000 kg
28.- The AC powered auxiliary fuel boost pump for the APU operates whenever the
APU is operating and no other pump is on. it has an alternate power source on the
AC Static Inverter bus for battery-only starts.
True.
False