Professional Documents
Culture Documents
Exam Sheet B 11
Exam Sheet B 11
a) Sunshade
b) Cool Water
c) Training
d) Written Procedure
f) a, b, c only
a) A good spray
b) No wind
3) A crane is working near 2 meter deep excavation, minimum distance from the edge shall be:
a) 1 Meter
b) 2 Meter
c) 3 Meter
5) When grinding a piece of metal with a portable power grinder, the type of Personal Protective
Equipment required is:
b) Goggles only
6) The maximum voltage permitted for portable power tool in construction site is:
a) 110 Volt
b) 220 Volt
c) 240 Volt
d) 150 Volt
7) Flammable materials storage area cannot be located within_________ of other buildings or structure.
a) 25 ft
b) 50 ft
c) 50 Meters
d) 100 ft
8) The ratio of vertical to horizontal spacing for a straight or extension ladder is:
a) 1 to 1
b) 2 to 1
c) 3 to 1
d) 4 to 1
9) A straight or extension ladder must extend over the edge of a roof , excavation, or scaffold platform
by minimum distance:
a) 1 foot
b) 4 feet
c) 0.9 meter
d) No ser distance
10) The Saudi Aramco General Instruction which sets forth the Work Permit Receiver’s requirement is:
a) GI 1.200
b) GI 5.430
c) GI 2.100
d) GI 6.200
11) If someone is injured on your job site, a preliminary written report must submitted to the Saudi
Aramco PMT within _________ period of time:
a) 2 Hours
b) 24 Hours
c) 8 Hours
d) 3 Days
12) Work platforms must have toe boards, top rails and access ladders once they reach a height of_____:
a) 4 ft
b) 8 ft
c) 6 ft
d) When the height is four times greater than the base width
13) Excavation “Spoils” must be set back a minimum of _____ from the sides of the excavation.
a) 1 Meter
b) 6 feet
c) 3 feet
d) 2 feet
a) 7
b) 8
c) 15
d) 19.50
15) During storage of oxygen and acetylene gas cylinders they must be separated by (1) A fire Resistant
wall or (2) a Distance of______:
a) 20 feet
b) 50 feet
a) Type A
b) Type B
c) Type C
18) What is necessary for a worker to wear on a steel beam six feet of more above ground?
20) Which of the following factors does affect the load capacity of a mobile crane?
a) Boom length
b) Boom angle
21) How many clips are required to construct an eye in a one half inch wire rope?
22) Class “B” fires involve flammable liquids or gases that could be under pressure. What would give you
most concern when selecting a Class “B” fire extinguisher?
a) 1 Month
b) 1 Week
c) 1 Shift
d) 1 Day
a) 10 ft
b) 15 ft
c) 50 ft
d) 25 ft
25) When transferring an extremely flammable liquid from a 55 gallon drum via a drum a hand pump to a
small metal can, which of the following provides the best protection?
26) A small mobile crane with rubber tires has struck a power line. The line, which I s now believed to be
dead, is lying across the crane boom. Which of the following best describes the proper course of
action for the crane operator?
c) Have the oiler knock the line from the boom with a wood pole
d) Swing the boom back and forth until the line breaks or fall off
27) When checking the ground on a duplex outlet, which of the following provides the best method?
a) Check the continuity between the block and the white wire
b) Check the continuity between green wire and the outlet box
c) Check the continuity between white wire and the outlet box
d) Check the continuity between green wire and the building ground
28) Which of the following is true concerning explosive proof equipment? Explosive proof equipment is allowed to
operate in a flammable or explosive atmosphere because it is capable of:
29) Minimum period of time the appointed “fire watch” remain at the site of HOT work after the activity
has stopped
a) 10 minutes
b) 15 minutes
c) 30 minutes
d) 60 minutes
c) To determine the length of the wire rope that has been extended
31) What are the most important self-developed skill of a site safety officer?
a) Explosive atmosphere
33) When lifting over or adjacent to process piping, etc .what is required?
a) Hold tag
b) Welding Machine
c) Rigger 3
d) Hot work
e) All of above
b) Guys
c) Tag line
d) Shackles
e) All of above
35) If you found a fire exit blocked by a wooden pallet what would you do?
a) Leave it
c) Move it immediately
b) Signed by Operator
37) What is the permissible noise exposure for an eight hours work shift?
a) 80
b) 90
c) 100
d) 120
38) What is the purpose of a hold tag?
d) All of above
39) Hold tags and locks are primary intended to protect the individual who is doing the work from?
d) Sleeping
a) True
b) False
2) Portable power tools being operated from an onsite generator need not be protected by a GFCI to be
consistent with the Saudi Aramco CSM
A) True
B) False
3) Excavation not subjected to vehicle traffic may barricaded using Red and White warning tape
a) True
b) False
4) The new heavy plastic % gallon drums may be used to store. Transport, and dispense diesel fuel only
a) True
b) False
5) Cigarette smoking is forbidden anywhere on Saudi Aramco construction sites except in designated
and approved smoking shelters.
a) True
b) False
6) Hole may be drilled into sides of hard hats to provide for cross ventilation air flow during very hot
weather
a) True
b) False
b) False
8) Soap and paper towel must be provided for the men to clean up before meal
a) True
b) False
9) Push sticks must be used when guiding wood work into a table saw
a) True
b) False
10) Rubber boots must be provided for person engaged in the pouring of concrete
a) True
b) False
11) When wearing rubber boots for pours, it is not necessary to have your steel toe shoes on
a) True
b) False
12) Placing as 8’2” X 12” board over two 20 –liter paint cane is allowed for temporary work platform
a) True
b) False
13) Formwork boards should be removed to the de nailing area as soon as possible after they are
disassembled.
a) True
b) False
14) A fire extinguisher must be placed near (5 to 15 feet) to any combustible engine being operated on
site
a) True
b) False
15) Tool box safety briefing must be held at site once I n a week.
a) True
b) False
16) Methane is not an odorless and tasteless gas that in non toxic
a) True
b) False
17) Hand held power tool such as drill and grinders may be locked on if the job is going to take a long
period of time to accomplish
a) True
b) False
18) Permanent scaffold should be secured by tying off to a firm portion of the structure every 26 ft
a) True
b) False
19) Scaffold planks must be at least 2” thick by 9” wide or up to 2” thick by 12” wide
a) True
b) False
20) Scaffold planks must be tied to or otherwise secured to the scaffold bearers
a) True
b) False
21) The windsocks in Saudi Aramco facilities are to let people know in which direction a gas or chemical
leak will flow
a) True
b) False
22) A safety officer must tour the site several times a day because condition are changing constantly
during construction activities
a) True
b) False
23) Dangerous safety hazards should be noted and kept in writing so that they can be reported at next
safety meeting
a) True
b) False
24) A weekly safety inspection of each area should carried out and a report of defects given to those
responsible for correcting them
a) True
b) False
25) A safety officer should check all construction activities only. The personnel officer checks the
medical facilities, toilet, drinking water and all things affecting health and welfare
a) True
b) False
26) When hot tapping gasoline lines, it is very important to establish and maintain product flow
a) True
b) False
27) It is okay to bring chemicals on site without a MSDS if you only have 20 liters of liquid or 10 cubic
meters of a toxic gas
a) True
b) False
28) Crane operation must be stopped when the wind speed is over 10 mph
a) True
b) False
a) True
b) False
30) Before use, all new lifting equipments should be subjected to a proof load test
a) True
b) False
31) Respiratory protective devices can be classified as , air purifying, supplied air, and self contained
breathing devices
a) True
b) False
32) When performing excavation work and there is no known underground utilities, or suspected
utilities, it is permissible to use mechanical equipment to excavate
a) True
b) False
33) A PFAS with a shock absorbing lanyard is required protection when working at 10 feet height to the
lower level
a) True
b) False
34) A scaffold tag is NOT required for scaffold less than 6 feet in height
a) True
b) False
35) Primary requirement in a confined space entry permit is gas testing by a worker
a) True
b) False
36) The ratio of number of portable toilets to number of workers at site is 1:15
a) True
b) False
a) True
b) False
38) The minimum clearance between building in lay down yards is 50 feet
A) True
B) False
a) True
b) False
40) The minimum aisle width in lay down yards is 3 meters
a) True
b) False
A B
g
1 Loose Soil A Standard spacing between fire extinguisher
L
2 1.2 meter deep excavation B 120 meters
a
3 50 feet C 150% times
b
4 Maximum distance between fire hydrants D 25 feet clearance
E
5 Certified operator E Crane
N
6 Common drinking cup F No work on height
P
7 Fire water minimum discharge pressure G Type C
C
8 Out rigger mats to pads H Man lift activity
I
9 Distance between lay down yard & building I 16 meters
J
10 25 kph J Man basket operation
Q
11 First aid facilities K Bed-space allocation per worker
H
12 Properly anchored PFAS L Confined space
D
13 More than 250,000 volts M Well ventilated
T
14 Approval of a critical lift plan N Prohibited
F
15 40 kph O All types of fire except metal fires
S
16 BC dry chemical fire extinguisher P 80 psig
R
17 32 kph Q MMSR
M
18 Laundry, toilets bathroom R Crane lifting operations
K
19 50 square feet S Purple K
o
20 ABC dry chemical fire extinguisher T Rigger I