Young's modulus of elasticity fora material can be calculated Density and velocity
indirectly from which of the following properties of the material? of sound in the
material
What temperature gradient must existin an aluminum rod foritto 16°C/em
transmit 8 cal per second per cm? of cross section down the rod?
Thermal conductivity of aluminum is 210 W/Km
Steel can be strengthened by all of the following practices EXCEPT: Annealing
Any motor application shail be considered as_dutyunless continuous
‘the nature of the apparatus it drives is such that the motor will not
‘operate continuously with load under any condition of use.
The critical angle for ight passing from rock salt into airis 40: 154
Calculate the index of refraction of rock salt.
‘What is the wavelength of light in water (n= 1.33)? auinm
What is the speed of light in water (n= 1.33)? 2.25% 10° m/s
The speed of light ina certain glassis L91 x 10° m/s. Whatisthe 1.57
refractive index of the glass?
Athin homogeneous metallic plate containing a hole is heated Increase at the same
sufficiently to cause expansion. Ifthe coafficient of surface rate asthe area of
‘expansion is linear, the area of the hole wilt: the metal increases.
Force/Area = lengthn/change in length elastic range
Whatiis the frequency of light which hasa wavelength in air of S46 549 THz
mm
Abeam of light strikes the surface of water at an incidence angle of 60° reflected into air,
(60°. Determine the directions of the reflected and refracted rays. 41° refracted into
For water, n=1.33, waterB
u
15
16
a
19
20
au
‘The relationship between the expansion of a spring and the force
required to produce the extension is:
No-metallic sheathed cable shall not be permitted forthe
installation in the following locations EXCEPT:
If 1080 steel (0.80 wt. % C) is annealed by very slow cooling from
1000°C to ambient temperature, its microstructure will consist
almost solely of:
How many grams of water at 100°C can be evaporated per hour
per cm? by the heat transmitted through a steel plate 0.20¢m
thick, ifthe temperature difference between the plate faces is,
100°C? For steel, thermal conductivity is 42 W/K-m
Hooke's law for an isotropic homogeneous medium experiencing
one-dimensional stress is:
Which of the following listed materials is considered among the
best insulation material for motor rewinding?
‘Acertain double-pane window consists of two glass sheets, each
80 crn x 80 cm x 0.3 cm, separated by a 0.3 cm stagnant air space.
The indoor surface temperature is 20°C, while the outdoor surface
‘temperature is exactly 0°C, How much heat passes through the
window each second? Thermal conductiviti
0.84 W/Km and 0.080 W/K'm, respectively.
forglass and air are
The absolute indices of refraction of diamond and crown glass are
5/2 and 3/2 respectively. Compute the refractive index of diamond
relative to crown glass.
Equipment to be installed shall be fully specified in the name plate
EXCEPT which of the following considered optional?
‘Asingle thickness glass window on a house actually has layers of
stagnant airon its two surfaces. But iit did not, how much heat
would flow out of an 80 cm x 40 cm3mm window each hour ona
day when the outside temperature was precisely O°C and the
inside temperature was 18°C? For glass, thermal conductivity is
osawem
dry location
Austenite
0.33 kg/hrem?
Fish paper
68 cal/s
58
Date Manufactured.
14x 10° keal/hr24
25,
Modulus of resilience is:
‘What is the metric size equivalent of 1,000 MCM?
The modulus of rigidity of steel
Ameasure of a
material ability to
store strain energy
500 mm?
Defined as the unit
shear stress divided
by the unit shear
deformation