Professional Documents
Culture Documents
3rd Periodical Test Epas-11
3rd Periodical Test Epas-11
I. Multiple Choice:
Direction: Choose the best answer; write only the letter of your choice in your answer sheet. (50 Items)
35. A certain electronic device does not work properly after you have soldered some of the components, upon checking,
you noticed defective components due to overheating, in what general classification of maintenance problem does it
belong?
A. mechanical failure C. chemical failure
B. thermal failure D. short run maintenance problem
36. A technical drawing with 3 equal axes and 3 equal angles.
A. dimetric projection C. isometric projection
B. orthographic projection D. None of the above
2
37. Maintenance procedure minimize production capacity of an equipment.
A. True C. unknown
B. False D. maybe
38. A specific electronic device was not functioning, upon checking of the component, you noticed corrosion on the
connection of the components, in what general classification of maintenance problems does it belong?
A. mechanical failure C. chemical failure
B. thermal failure D. short run maintenance problem
39. A type of technical drawing which has zero equal axes and zero equal angles
A. dimetric projection C. isometric projection
B. trimetric projection D. None of the above
40. A type of projection that is consists of three-dimensional drawings.
A. oblique projection C. isometric projection
B. orthographic projection D. axonometric projection
41. Which of the following might not be needed in a power supply?
A. The transformer. C. The rectifier.
B. The filter. D. All of the above are generally needed.
42. Inside the workplace, frequent loud noises were being experienced by all of the technicians, in what type of hazard
does it belong?
A. chemical hazard C. physical hazard
B. biological hazards D. ergonomic hazard
43. A workplace is infested with dengue carrying mosquitos, it is the result of unclean surroundings;
A. chemical hazard C. physical hazard
B. biological hazards D. ergonomic hazard
44. It is the possibility of being harmed or injured.
A. hazard C. danger
B. risk D. accident
45. In cavalier projection, one of the 3 planes are drafted to represent a plane of an object according to half of the given
scale.
A. True C. unknown
B. False D. maybe
46. In cabinet projection, one of the 3 planes are drafted to represent half of a plane of an object according to a given
scale.
A. True C. unknown
B. False D. maybe
47. If a fuse blows, and it is replaced with one having a lower current rating, there’s a good chance that:
A. The power supply will be severely damaged.
B. The diodes will not rectify.
C. The fuse will blow out right away.
D. Transient suppressors won’t work.
48. To service a power supply with which you are not completely familiar, you should:
A. Install bleeder resistors.
B. Use proper fusing.
C. Leave it alone and have a professional work on it
D. Use a voltage regulator
49. A fuse with nothing but a straight wire inside is probably:
A. A slow-blow type. C. of a low current rating.
B. A quick-break type D. of a high current rating.
50. Type of maintenance performed continuously or at intervals according to the requirements to diagnose and monitor
a condition or system:
A. preventive maintenance C. predictive maintenance
B. corrective maintenance D. running maintenance
3
"Acquire new knowledge whilst thinking over the old, and you may become a
teacher of others."
4
.
5
6
7