Professional Documents
Culture Documents
2019 Engine G 3.3 MPI LAMBDA II Schematic Diagrams Engine Electrical System Smart Cruise Control (SCC) System Service Tips
2019 Engine G 3.3 MPI LAMBDA II Schematic Diagrams Engine Electrical System Smart Cruise Control (SCC) System Service Tips
2019 > Engine > G 3.3 MPI LAMBDA II > Schematic Diagrams > Engine Electrical System > Smart Cruise
Control(SCC) System > Service Tips
Smart Cruise Control (SCC) System Service Tips (2)
9) When pressed 'OFF' switch in any mode, SCC system goes to ' OFF C1102 Battery power low Check battery, charger, cables, connectors
Front left wheel speed sensor CAN
MODE'. C1202 Check ESP DTC (C1360 duplicate detection)
signal malfunction
2. SCC control mode
Front right wheel speed sensor CAN
1) Low speed control C1205 Check ESP DTC (C1360 duplicate detection)
signal malfunction
SCC system performs speed/distance control in certain speed of vehicle Rear left wheel speed sensor CAN
C1208 Check ESP DTC (C1360 duplicate detection)
(30~180 km/h). But speed of vehicle less than 30km/h, SCC system will signal malfunction
not performs speed control. Rear right wheel speed sensor CAN
C1211 Check ESP DTC (C1360 duplicate detection)
2) Overdrive control signal malfunction
Steering angle sensor CAN
When press accelerator pedal, vehicle will accelerate even in SCC C1260 Check SAS(Or MDPS) DTC
signal malfunction
control mode because driver control has more priority than system
Yaw-rate sensor CAN
control. After release accelerator pedal, vehicle will decelerate to set C1283 Check ESP DTC (C1360 duplicate detection)
signal malfunction
speed of vehicle. C1360 ESP torque control malfunction Check ESP DTC
https://www.kia-hotline.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=PA 1/1