Professional Documents
Culture Documents
TRIETHYLENE GLYCOL - CAMEO Chemicals - NOAA
TRIETHYLENE GLYCOL - CAMEO Chemicals - NOAA
TRIETHYLENE GLYCOL - CAMEO Chemicals - NOAA
Chemical Datasheet
Add to MyChemicals
Print Friendly Page
Help
TRIETHYLENE GLYCOL
Search Chemicals
New Search
Chemical Identifiers | Hazards | Response Recommendations |
Physical Properties |
Regulatory Information | Alternate Chemical Names
View MyChemicals
Predict Reactivity
CAS Number UN/NA Number DOT Hazard Label USCG CHRIS Code
112-27-6 none data unavailable
TEG
Mobile Site
NIOSH Pocket Guide International Chem Safety Card
none TRIETHYLENE GLYCOL
NFPA 704
Special
(NFPA, 2010)
General Description
Colorless liquid with a mild odor. Dense than water. (USCG, 1999)
Hazards
What is this information?
Reactivity Alerts
none
Fire Hazard
This chemical is combustible. (NTP, 1992)
Health Hazard
Vapor and liquid are unlikely to cause harm. (USCG, 1999)
Reactivity Profile
TRIETHYLENE GLYCOL is a ether-alcohol derivative. The ether being relatively unreactive.
Flammable and/or toxic gases are generated by the combination of alcohols with alkali
metals, nitrides, and strong reducing agents. They react with oxoacids and carboxylic acids to
form esters plus water. Oxidizing agents convert alcohols to aldehydes or ketones. Alcohols
exhibit both weak acid and weak base behavior. They may initiate the polymerization of
isocyanates and epoxides. Reacts with strong oxidants. [Handling Chemicals Safely 1980. p.
932].
Use caution: Liquids with this reactive group classification have been
known to react with the
absorbent
listed below.
More info about absorbents, including situations to watch out for...
Cellulose-Based Absorbents
Response Recommendations
What is this information?
Firefighting
Fire Extinguishing Agents Not to Be Used: Water or foam may cause frothing.
Fire Extinguishing Agents: Alcohol foam, dry chemical, or carbon dioxide (USCG, 1999)
Non-Fire Response
SMALL SPILLS AND LEAKAGE: If you spill this chemical, use absorbent paper to pick up all
liquid spill material. Seal the absorbent paper, as well as any of your clothing which may be
contaminated, in a vapor-tight plastic bag for eventual disposal. Wash any surfaces you may
have contaminated with a soap and water solution. Do not reenter the contaminated area
until the Safety Officer (or other responsible person) has verified that the area has been
properly cleaned.
STORAGE PRECAUTIONS: You should keep this material in a tightly closed container under an
inert atmosphere, and store it at refrigerated temperatures. (NTP, 1992)
Protective Clothing
Goggles; plastic gloves. (USCG, 1999)
First Aid
EYES: First check the victim for contact lenses and remove if present. Flush victim's eyes with
water or normal saline solution for 20 to 30 minutes while simultaneously calling a hospital or
poison control center. Do not put any ointments, oils, or medication in the victim's eyes
without specific instructions from a physician. IMMEDIATELY transport the victim after
flushing eyes to a hospital even if no symptoms (such as redness or irritation) develop.
SKIN: IMMEDIATELY flood affected skin with water while removing and isolating all
contaminated clothing. Gently wash all affected skin areas thoroughly with soap and water. If
symptoms such as redness or irritation develop, IMMEDIATELY call a physician and be
prepared to transport the victim to a hospital for treatment.
INHALATION: IMMEDIATELY leave the contaminated area; take deep breaths of fresh air. If
symptoms (such as wheezing, coughing, shortness of breath, or burning in the mouth,
throat, or chest) develop, call a physician and be prepared to transport the victim to a
hospital. Provide proper respiratory protection to rescuers entering an unknown atmosphere.
Whenever possible, Self-Contained Breathing Apparatus (SCBA) should be used; if not
available, use a level of protection greater than or equal to that advised under Protective
Clothing.
INGESTION: DO NOT INDUCE VOMITING. If the victim is conscious and not convulsing, give 1
or 2 glasses of water to dilute the chemical and IMMEDIATELY call a hospital or poison control
center. Be prepared to transport the victim to a hospital if advised by a physician. If the
victim is convulsing or unconscious, do not give anything by mouth, ensure that the victim's
airway is open and lay the victim on his/her side with the head lower than the body. DO NOT
INDUCE VOMITING. IMMEDIATELY transport the victim to a hospital. (NTP, 1992)
Physical Properties
What is this information?
Regulatory Information
What is this information?
1,2-BIS(2-HYDROXYETHOXY)ETHANE
1,2-DI(BETA-HYDROXYETHOXY)ETHANE
DI-BETA-HYDROXYETHOXYETHANE
1,8-DIHYDROXY-3,6-DIOXAOCTANE
3,6-DIOXAOCTANE-1,8-DIOL
2,2'-(1,2-ETHANEDIYLBIS(OXY))BISETHANOL
ETHYLENE GLYCOL DIHYDROXYDIETHYL ETHER
ETHYLENE GLYCOL-BIS-(2-HYDROXYETHYL)ETHER
2,2'-ETHYLENEDIOXYBIS(ETHANOL)
2,2'-ETHYLENEDIOXYDIETHANOL
2,2'-ETHYLENEDIOXYETHANOL
GLYCOL BIS(HYDROXYETHYL) ETHER
2-[2-(2-HYDROXYETHOXY)ETHOXY]ETHANOL
TEG
TEG (GLYCOL)
TRIETHYLENE GLYCOL
TRIETHYLENE GLYCOL DIMALEATE
TRIGEN
TRIGLYCOL
TRIGOL
About |
Privacy Policy |
Contact Us
|
Website Satisfaction Survey |
Mobile Site