Professional Documents
Culture Documents
Test Interior TML y Cambio de Plaza
Test Interior TML y Cambio de Plaza
Test Interior TML y Cambio de Plaza
ATA 6
1. What is the zone where is located the lower half of the fuselage to aft pressure bulkhead?
a) Zone 100
b) Zone 200
c) Zone 800
2. Which is the subzone that identified the vertical stabilizer?
a) Sub Zone 300
b) Sub Zone 320
c) Sub Zone 700
3. Which is the subzone that identified the main wheel well?
a) Sub Zone 125 and 126
b) Sub Zone 197 and 198
c) Sub Zone 734 and 744
4. What is the zone where are located the doors?
Zone 800
5. The airplane is divided into?
Station, wireline and button line
ATA 11
6. What of the following types of placards are specified in the ATA 100 specifications?
a) Security data
b) Safety data
c) Standard data
7. How many types of placard and marking are the in the ATA 100?
a) 4
b) 3
c) 5
8. What placard are used in servicing and maintenance instruction?
a) Safety data
b) Maintenance data
c) Safety maintenance
9. Which is the type of label that is made in metal foil for use in skydrol zones?
a) Fotofoil type N°3
b) Fotofoil type N°2
c) Fotofoil type N°1
10. Which are the dimensions to the labels that are used to identified functional description of equipment?
15mm height, 45mm wide, 32mm height letters
ATA 12
11. How many servicing operations there are in according ATA 12?
a) 5
b) 3
c) 2
12. What kind of type of servicing operation is the check APU oil level?
a) Unscheduled servicing
b) Replenishing servicing
c) Scheduled servicing
13. What kind of type of servicing operation is the system line flushing?
a) Unscheduled servicing
b) Replenishing servicing
c) Scheduled servicing
14. Which of the following servicing operations are unscheduled?
Sampling for analysis
25. What is the objective of a dual loop system is installed in the cargo compartment ceiling panel?
a) Prevent a warning system failure
b) To active the extinguishing bottles
c) Gives warning signal to the crew
26. Where is located the ELT?
a) In the cockpit
b) In the E&E compartment
c) Aft pax cabin
27. Which is the objective to prevent a pressure difference between different closed areas in the aircraft?
a) This prevents high pressure into de paxcabin
b) This prevents structural damage to the fuselage, to the equipment and furnishings
c) This prevents low pressure in the pax cabin
28. Where is the inflation reservoir of the escape slide of emergency exit located?
a) In a container at the bottom of the door
b) In the overhead stowage compartment over the door
c) In the cargo compartment
29. Where is the inflation reservoir of the escape slide of emergency exit located, on aircraft A321?
a) In container at the bottom of the door
b) In the overhead stowage compartment over the bin door
c) In the cargo compartment
30. Who is the responsible to operate the evacuation signaling equipment in an emergency (on the ground or on water) if
the aircraft has to be evacuated?
a) By captain or purser
b) By the any person
c) No exist responsible person
31. How many frequencies do the ELT operates on?
a) 3
b) 4
c) 2
32. Where is installed the slides rafts?
a) Are installed at the FWD and aft passenger/crew doors
b) Are installed at the FWD and aft cargo doors
c) Are installed at the exit door
33. How is classified the FWD and AFT cargo compartment?
Class “C” compartment.
34. What is the function of the rapid-decompression safety-system?
Prevent a pressure different between different areas in the aircraft
37. Where is sent the water which comes from the galley and lavatory washbasins?
a) Is sent to the water tank
b) Is discarded through the drain lines and mast drained to atmosphere
c) Is sent to the waste holding tank
ATA 35 OXIGEN
47. What is the component of the oxygen system that is used to supply oxygen to one crew member if there fire or
emission of smoke?
a) Fire detector system
b) Air conditioner system
c) Protective Breading equipment
48. What does the flag OXY ON indicate when the stowage box doors are open?
a) The oxygen system is empty
b) The oxygen is flowing
c) The oxygen is no flowing
49. How many minutes of oxygen give the chemical oxygen generator?
a) 12 minutes
b) 13 minutes
c) 15 minutes
50. When does operate the low-pressure switch installed on the distribution manifold?
Its operate when the oxygen supply pressure decrease to 3.45 plus or 0.35 bar
51. What is the element that isolates the water faucet and the toilet from the potable water distribution system?
a) Water heater
b) Manual shut off valve
c) Over pressure relief valve
52. What are the colors of the water edification in the mix valve?
a) Red and blue
b) Black and red
c) Blue and black
53. Where is located the quantity indicator?
a) In the fwd and aft attendant panel
b) In the fwd attendant panel and service panel
c) Aft attendant panel and service panel
54. What is the water conditioner?
a) Is a magnetic permanent unit
b) Is solenoid controlled
c) Is devices that redirect the flow water
55. Where is located the fill/drain control handle?
a) On the potable water service panel
b) In the cockpit
c) In the galley panel
56. Where is location the quantity transmitter?
a) Panel service door
b) On the top of portable water tank
c) In the galley panel
57. What is the function of water quantity transmitter?
Monitor the volume of the water remain in the tank
58. What is the function of light emitting diode?
Show the water content in dose of volume.
59. What is the function of the compressed air in the water and waste system?
Supply water of the tank with air
ATA52 DOORS