Professional Documents
Culture Documents
Metal Protective Oil
Metal Protective Oil
Metal Protective Oil
FEATURED BENEFITS
• Provides short-term protection for acid, salt, and high
humidity conditions
• High flash point
• No heavy metals, pleasant odor, safe handling
• Can be used as a light duty lubricant
APPROVALS
• CAT IE 4971 Certified - Short-Term Indoor Storage COMPATIBLE METALS
Carbon Steel
Stainless Steel
Cast Iron
Copper
Aluminum
TYPICAL APPLICATIONS
Machined Parts
Engines
Forged Hot Parts
Steel Plate
Parts Storage
TYPICAL PROPERTIES
Fluid Type Oil based rust inhibitor
Appearance Clear amber liquid
Film Type Oily translucent
Dry Film Thickness, Dipped, 77°F (25°C) 1 mil (25μ)
Weight, 77°F (25°C) 7.51 lbs/gal.
VOC, EPA Method 24 0.56 lbs/gal.
Flash Point, PMCC 260°F (127°C)
Coverage, 2 Mil WFT 550 sq ft/gal.
Cure Time, 77°F (25°C), 45% RH Immediate
Viscosity, 40°C 18 cSt
PROTECTION PROPERTIES
20 Ra (Smooth)
Test Dry Film Thickness 1010 Carbon Steel Panels
Humidity ASTM D 1748 1 Mil (25μ) 240 hours
Indoor Warehouse 1 Mil (25μ) 3 months
30 | www.chemtool.com
METAL PROTECTIVE OIL L
TECHNICAL DATA
PRODUCT APPLICATION
Metal Protective Oil L is designed primarily for indoor protection only.
Metal Protective Oil L may be applied by brushing, spraying, or dipping. Maximum performance of Metal Protective Oil L can be
achieved only when the metal surfaces are clean, free of rust, water, ice and mill scale. The metal substrate should be at a tem-
perature of 50° to 95°F (10° to 35°C) at the time of product application. Metal Protective Oil L is formulated to be used as supplied.
DO NOT THIN Metal Protective Oil L. Incorrect thinning will compromise film build, dry time, and coverage. Ensure uniform consis-
tency prior to use.
Normally a single tank is adequate for dipping operations, however, if parts are extremely wet or dirty and where carry-over is
great, a two-tank system will produce the best results. Where water displacement is of primary importance, the dip tank should be
equipped with a bottom drain for removing accumulated water. A false bottom tank is desirable to prevent parts from being dipped
through rust preventative into water layer below.
DO NOT HERMETICALLY SEAL BAGS IF BAGGING PARTS.
RECOMMENDED SPRAY EQUIPMENT: Metal Protective Oil L is a ready to use product. The viscosity is low enough to be easily
sprayed using a pneumatic spray gun/body shutz gun or pressure pot. Airless spray equipment is not required but can be used if
other methods are not available.
www.chemtool.com | 31