Professional Documents
Culture Documents
b2020-Tdc-Fas-004 Fasteners r3
b2020-Tdc-Fas-004 Fasteners r3
S. No.: DESCRIPTION
Code/Year & Addenda of Edition : ASME Sec. VIII DIV. I, Edition 2019
1. ASME Sec. II Part A, Edition 2019
Specification & Grade : Bolt - ASME A193 B7
2. Nut – ASME A194 2H.
Washer – A36
Size & Pressure Class Rating,
3.
Quantity & Dimension : Refer Table-1
4. Additional Requirements if any:
Bolt: -
Alloy Steel Bolting Material for pressure vessel as per ASME Sec. II Part A 2019 Edition.
1- The steel shall be made by open-hearth, basic-oxygen, electric-furnace, or Vacuum –
induction melting process as per specification SA 320 section (4).
2- Material, Mechanical requirements, Mechanical Properties, Chemical Properties as per
Specification SA 193
3- Bolt shall be thread in accordance with ASME B1.1 UNC Class 2A-sizes 1” and smaller
ASME B1.1 UN8 Class 2A-sizes 1-1/8 and larger.
4- Heat Treatment requirement as per specification SA 320 section (5).
5- Tensile strength and Hardness test as per specification SA 320 (6)
6- Bolt dimensions as per specification ASME B16.5
7- Bolt head dimensions as per specification ANSI 18.2.1.
8- Negative tolerance is not permitted on the length of the bolting.
Nut: -
Alloy Steel Nut Material for pressure vessel as per ASME Sec. II Part A 2019 Edition.
9- The steel shall be made by open-hearth, basic-oxygen, electric-furnace, or Vacuum –
induction melting process as per specification SA 194 (5).
10- Material, Mechanical Properties, Chemical Properties as per Specification SA 194
11- Nut shall be thread in accordance with ASME B1.1.
12- Nut dimensions are per specification ANSI B18.2.2.
13- Nut proof test as per specification ASME A194
Washer: -
14- The washer shall be free from cracks, burrs, pits and other defects. The hole shall be
reasonably concentric with the outer periphery. All sharp edges shall be removed.
15- Washer dimensions as per ASME F436
16- Washer should be free from radioactive and mercury contamination
General: -
17- Finish: Light Protective Oil
18- All the thread Profile of fasteners should be smooth and free from burrs.
19- Quantity dimensions: refer the table – 1
TABLE-1
02 AI comments incorporated & bolt Lg. changed in table-1 M.A R.P.K 1.10.2020
Bolt - Heat treatment requirement section changed and
Nut Impact and Charpy Note deleted
01 AI Comments incorporated M.A R.P.K 29.09.2020
Rev No. Description Prepared Approved Date
REVISION STATUS
Signature: