Professional Documents
Culture Documents
Diode Application
Diode Application
Diode Application
Tacloban City
COLLEGE OF ENGINEERING
Experiment # 1
TRANSFORMER:
Procedure:
2. Adjust the transformer turns ratio to have an output voltage of 12V rms in figure (a)and (b). Input at the primary
must be 220 V AC. Use same transformer ratio in circuit c.
3. Measure the output voltage as shown above using multimeter. Screenshot and paste the results below.
Results:
Sample only
Results:
Sample only
By calculation solve:
Effective voltage (Vrms) = _____
(a)
By calculation solve:
Effective voltage (Vrms) = _____
(b)
By calculation solve:
Effective voltage (Vrms) = _____
(c)
RECTIFIER
5. Connect a half wave rectifier shown in the figure then screenshots the output waveform:
(a)
(b)
(c)
Results.
By calculation solve:
Effective voltage (VAC) = _____
Average Voltage (VDC) = _____
Measured by multimeter:
VAC = ______
VDC = ______
(a)
By waveform observation determine:
Voltage peak (Vp) = _____
By calculation solve:
Effective voltage (VAC) = _____
Average Voltage (VDC) = _____
Measured by multimeter:
VAC = ______
VDC = ______
(b)
By waveform observation determine:
Voltage peak (Vp) = _____
By calculation solve:
Effective voltage (VAC) = _____
Average Voltage (VDC) = _____
Measured by multimeter:
VAC = ______
VDC = ______
(c)
6. Connect the full-wave center tapped as shown in the figure then screenshots the output waveforms.
Results:
By calculation solve:
Effective voltage (VAC) = _____
Average Voltage (VDC) = _____
Measured by multimeter:
VAC = ______
VDC = ______
7. Connect the full-wave bridge-type shown and draw the output waveform.
(a)
(b)
Results:
By calculation solve:
Effective voltage (VAC) = _____
Average Voltage (VDC) = _____
Measured by multimeter:
VAC = ______
VDC = ______
(a)
By waveform observation determine:
Voltage peak (Vp) = _____
By calculation solve:
Effective voltage (VAC) = _____
Average Voltage (VDC) = _____
Measured by multimeter:
VAC = ______
VDC = ______
(b)
FILTER CIRCUIT
8. Repeat procedure 5 to 7 with an electrolytic capacitor (4.7mF) connected in parallel with the resistor.
Screenshots your circuit and its equivalent results.
(a)
sample
(b)
(c)
Results
Measured by multimeter:
VDC = ______
(a)
Measured by multimeter:
VDC = ______
(b)
Measured by multimeter:
VDC = ______
(c)
Measured by multimeter:
VDC = ______
(b)
Results
Measured by multimeter:
VDC = ______
(a)
Measured by multimeter:
VDC = ______
(b)
SUMMARY OF RESULTS
Rectifier ckts Waveform By Calculation Multitester Results With Filter
Observation
Half-wave: Vp VAC VDC VAC VDC VDC VDC
(observed) (measured)
Circuit (a)
Circuit (b)
Circuit (c)
Center-
tapped
Bridge-type Vp VAC VDC VAC VDC VDC VDC
(observed) (measured)
Circuit (a)
Circuit (b)
OBSERVATIONS: (observations based from table)