Professional Documents
Culture Documents
Gate RLC
Gate RLC
Gate RLC
R2
b) R1 +R2
δ(t)
R2
c) R1 +R2
u(t)
Fig. 1 R2
1
d) R1 +R2
1 − e R1 C1 u(t)
Fig. 4
Fig. 7
resonance,the value of the coupling coefficient
K will be
Fig. 5
Fig. 8
a) 80V,32V,48V c) 20V,8V,12V
b) 80V,48V,32V d) 20V,12V,8V
Fig. 6
Fig. 9
Fig. 13
a) 10V c) 5V
Fig. 14
a) 3V b) -3V c) 5V d) None of
these
Fig. 15
14) The voltage V in the figure13 is always equal
to
4
16 8
a) 3
Ω c) 3
+ 12j Ω
8
b) 3
Ω d) None of above
Fig. 17
Fig. 16
Fig. 18
18) A communication channel has first order low b) Find the value of ε
pass transfer function.The channel is used to
transmit pulses at a symbol rate greater than
the half-power frequency of the low pass c) Find V2 when R=∞(open circuit)
function.Which of the network shown in the
figure17 is can be used to equalise the received
pulses?
Fig. 21
Fig. 20
a) 0.5V b) 3.0V c) 3.5V d) 4.0V
Fig. 22
b) kCL and Ohm’s law
a) 2 b) 4 c) 8 d) 10
Fig. 28
Fig. 25
Fig. 29
29) A Delta-connected network with its Wye-
equivalent is shown in Fig26,fig27.The resis-
tance R1 ,R2 and R3 (in ohms) are respectively
32) In the circuit of Fig.30 the voltage v(t)is
Fig. 30
Fig. 26
a) eat -ebt c) aeat -bebt
30) In the circuit of Fig.28,the switch ’S’ has b) high pass filter d) band reject filter
remained open for a long time. The switch
closes instantaneously at t=0
a) Find V0 for t≤0 and as t→ ∞
Fig. 34
Fig. 32
Fig. 35
35) For the circuit in figure.33
a) Find the Thevenin equivalent of the sub
38) The voltage e0 in figure36 is
circuit faced by the capacitor across the
terminals a,b. a) 2V b) 4
V c) 4V d) 8V
3
c) Find i(t),t>0
Fig. 36
37) For the circuit in figure35,write the state equa- b) 10Ω d) 28.28Ω
tions using vc and iL as state variables
8
Fig. 38
Fig. 39
Fig. 42
a) 25V c) -50V
Fig. 40
b) 50V d) 0V
b) Find e1 (0+ )
9
40
a) 16Ω b) 3
Ω c) 60Ω d) 20Ω
Fig. 46
a) 3 c) 6
47) The switch in Figure.45 has been in position1
for a long time and is then moved to position2 b) 4 d) 7
at t=0.
a) Determine Vc (0+ ) and IL (0+ )
dVc (t)
b) Determine dt
at t=0+
a) 25 b) 50 c) 100 d) 200
d2 i di
b) dt2
+2 dt +2i(t)=cost
55) The circuit for Q.55-56 is given in figure.50.
For both the questions, assume that the switch
2
d i di
c) 2 dt2 +2 dt +i(t)=cost S is in position1 for a long time and thrown to
position2 at t=0.At t=0+ , the current i1 is
−V −V
d) d2 i di
+2 dt +2i(t)=sint a) 2R
c) 4R
dt2
b) −V
R
d) zero
Fig. 48
5 1 6 3 Fig. 50
a) 6
Ω b) 6
Ω c) 5
Ω d) 2
Ω
1
R + Ls + Cs
−Ls I1 (s)
b) =
V −Ls R + C1s I2 (s)
−s
0
1
R + Ls + Cs
−Ls I1 (s)
c) 1 Fig. 51
−Ls R + Ls + Cs
I2 (s)
V
= s
0
a) 5sin(2t+53.1◦) c) 25sin(2t+53.1◦)
1
R + Ls + Cs
−Ls I1 (s)
d) 1 b) 5sin(2t-53.1◦) d) 25sin(2t-53.1◦)
−L s R + Ls + Cs
I2 (s)
V
−s
=
0
√ √
57) An input voltage v(t)=10 2 cos(t+10◦ )+10 3
cos(2t+10◦ )V is applied to a series combination
of resistance R=1Ω and an inductance L=1H.
Fig. 52
The resulting steady state current i(t) in ampere
is
a) 10 cos(t+55◦ )+10 cos(2t+10◦ +tan−1 2)
60) For the circuit shown in Figure.53,the time
q
3 constant
√ RC=1ms.The input voltage is
b) 10 cos(t+55◦ )+10 2
cos(2t + 55◦ ) v1 (t)= 2sin103 t.The output voltage v0 (t) is
equal to
c) 10 cos(t-35◦ )+10 cos(2t+10◦ − tan−1 2) a) sin(103t − 45◦ ) c) sin(103 t − 53◦ )
q
3
d) 10 cos(t-35◦ )+10 2
cos(2t − 35◦ ) b) sin(103t + 45◦ ) d) sin(103 t + 53◦ )
Fig. 53
b) L1 +L2 -M d) L1 +L2 -2M
59) The circuit shown in figure.52 with R= 13 W, 61) For the R-L circuit shown in Figure.54,the
L= 41 H, C=3F has input voltage v(t)=sin2t.The input voltage vi (t)=u(t).The current i(t) is
resulting current i(t) is
62) The circuit shown in Figure.55 has initial cur-
rent iL (0) = 1A through the inductor and an
12
106 106
b) s2 +103 s+106
d) s2 +106 s+106
Fig. 56
1
q
b) R≥ L d) R= √LC
C
Fig. 54
1
b) π
× 104 Hz d) 2π × 104 Hz
Fig. 58
Fig. 61
b) 0.138 V d) 1 V
Fig. 59
Fig. 62
68) Impedance Z as shown in figure.60 is:
a) j29Ω c) j19Ω
71) A square pulse of 3 volts amplitude is applied
b) j9Ω d) j39Ω to C-R circuit shown in figure.63. The capaci-
tor is initially uncharged. The ouput voltage v0
at time t=2 sec is
a) 3V b) -3V c) 4V d) -4V
Fig. 60
b) 4V, 32 Ω d) 4V,2Ω
Fig. 64
Fig. 65
c) 12.5∠30◦
d) 17∠30◦
Fig. 71
n
(B) u(t) + 2 Σ∞
n=1 (−1) u(t − nT )
n
(C) tu(t) + 2 Σ∞
n=1 (−1) (t − nT )u(t − nT )
1
√
c) √2 e− 2 tcos( 3 t)
3 2
t
√
d) √2 e− 2 sin( 3 t)
3 2
√ √
3t √1 sin( 3t )]
b) e −1
2
t[cos( 2
) − 3 2 a) 2.4Ω c) 4Ω
√ 8
c) √2 e− 1 tsin( 3t ) b) 3
Ω d) 6Ω
3 2 2
√
d) √2 e− 1 tcos( 3t )
3 2 2
R
b) 2
d) 2R Fig. 75
V0 V0
84) The switch in the figure.74 shown was on a) i(t)→ R
c) i(t)→ R
(1+B)
position a for a long time and is moved to
position b at time t=0 .The current i(t) for t> 0 b) i(t)→ 2V0
d) i(t)→ 2V0
(1+B)
R R
is given by
a) 0.2e−125t u(t) mA c) 0.2e−1250t u(t) mA 87) For parallel RLC circuit, which one of the
following statements is NOT correct?
b) 20e−1250t u(t) mA d) 20e−1000t u(t) mA a) The bandwidth of the circuit decreases if R
is increased.
85) In the figure.75 shown ,what value of RL b) The bandwidth of the circuit remains same
maximizes the power delivered to RL ? if L is increased.
17
b) ( V3p )sin( RC
t
) d) ( V2p )sin( RC
t
)
Fig. 76
a) 6.4-j4.8 c) 10+j0
Fig. 77
b) 6.56-j7.87 d) 16+j0
b) i(t)=5exp(-2×103t)A
Fig. 80
c) i(t)=10exp(-2×103t)A
a) 5Ω c) 15Ω
d) i(t)=-5exp(-2×103 t)A
b) 10Ω d) 20Ω
Fig. 83
Fig. 81
96) In the figure.84 shown below,the current
through the inductor is
94) In the figure.82 shown below, the current I is a) 2
A c) 1
A
1+j 1+j
equal to
a) 14∠0◦ A c) 2.8∠0◦ A −1 d) 0A
b) 1+j
A
b) 2.0∠0◦ A d) 3.2∠0◦ A
Fig. 82 Fig. 84
95) In the figure.83 shown below, the initial charge 97) The impedance looking into nodes 1 and 2 in
on the capacitor is 2.5 mC, with the voltage the given figure.85 is
19
a) 50Ω b) 100Ω c) 5KΩ d) 10.1kΩ 100) Assuming both the voltages sources are in
phase,the value of R for which maximum
power is transfered from circuit A to circuit
B is,figure.88
a) 0.8Ω c) 2Ω
Fig. 85
b) 1.4Ω d) 2.8Ω
V2 (s)
c) an exponentially decaying function 101) The transfer function V1 (s)
of the
figure.89shown below is
0.5s+1 s+2
d) an impulse function a) s+1
c) s+1
3s+6 s+1
b) s+2
d) s+2
Fig. 86
a) -5V b) 2V c) 3V d) 6V
a) 100∠90◦ c) 800∠90◦
Fig. 91
b) 2V1 - 25 V2
104) Find the current I in the following
Branch.,figure.92
c) −3
V -7V
2 1 2 2
11
d) -3V1 + V
2 2
Fig. 92
108) For the figure.96 given below, what will be the 111) In the figure.99 shown,at resonance,the ampli-
largest value of arm when it is converted into tude of the sinusoidal voltage(in Volts) across
delta form. the capacitor is
Fig. 99
Fig. 96
112) In the network shown in the figure.100, all
resistors are identical with R=300Ω. The re-
109) For the given figure.97, the value of capacitor sistance Rab (in Ω) of the network is
is in mF. So that the system will be critically
damped is
Fig. 100
Fig. 97
b) i3 =-4A
Fig. 102
Fig. 105
Fig. 104 B (i) and (iii) only D (iii) and (iv) only
Fig. 109
Fig. 108