Professional Documents
Culture Documents
Explo TQ
Explo TQ
Department of Education
Region I
Schools Division of Ilocos Norte
Pagudpud National High School
Pagudpud
44. From the picture given which of the following is a cutting lane line?
45. Based on the table above which of the following is a visible line?
46. From the picture given, which of the following is a center line?
47. What might happen if a person or draftsman does not master the alphabet of lines?
A. Draftsman might not have the ability to draw properly.
B. Draftsman will not be able to properly do his job.
C. Draftsman will have an exceptional work
D. Draftsman will have the best output.
48. In your own opinion is it important to know the alphabet of lines?
A. Yes, because it will make your work more faster.
B. Yes, because it is the basic of being a draftsman.
C. No, because anyone can draw line.
D. No, because it is just lines.
49. What is the the third color from the color coding chart?
A. Black C. Green
B. Orange D. Red
50. What is the sixth color from the color coding chart?
A. Black C. Green
B. Orange D. Red
51. If the color black in the color coding chart has the 1st band value of 0, what is its multiplier value?
A. x0 C. x100
B. x0 D. x1000
52. If the color brown has the 1st band value of 1 what is its multiplier value?
A. x0 C. x100
B. x10 D. x1000
53. A resistor has color Blue Black Red Gold. What is the value of the third color?
A. 2 C. x10
B. 3 D. x100
54. Susan saw a resistor on the floor which has the color Brown Black Orange Gold. What is its value?
A. 10000±5% C. 100000±5%
B. 100±5% D. 100±10%
55. Professor Escanor showed a resistor in its class the colors indicated are Black Blue Red Gold, what is the
value of Gold?
A. ±10% C. ±15%
B. ±20± D. ±100%
56. What is the minimum value of a resistor which has the color Blue Red Brown Gold?
A. 500Ὠ C. 580Ὠ
B. 508Ὠ D. 589Ὠ
57. Is it important to know how to decode resistor?
A. Yes, because it is important in repairing.
B. Yes, because it is a important to know the different value of the resistor.
C. No, because you can even repair without knowing it.
D. No, because it is just an extra lesson.
58. How will you decode a resistor without using the color coding chart?
A. Through mnemonics C. Through counting the bands of the resistor
B. Through multitester D. You cannot decode without looking at the chart.
59. If a resistor is lower than its minimum resistance, would it be still considered as a good resistor?
A. Yes, as long as it is not too low than the decoded resistance.
B. Yes, because it would still be working unless burnt.
C. No, because it is already out of its range.
D. No, because it should always be at the max resistance.
60. The decoded resistor is 550±5% Ohms and if measured in the multitester it is 510. Would you consider it a
defective resistor?
A. Yes, because it is out of the decoded range.
B. Yes, because it is still in its range.
C. No, because it is out of the recorded range.
D. No, because it is too high.