Professional Documents
Culture Documents
Elkfr 26 GTN 2 Ya
Elkfr 26 GTN 2 Ya
Ltd
Indoor Models
[A SERIES] [B SERIES]
EL-KFR26G/TN2Y-A EL-KFR26G/TN2Y-B
EL-KFR36G/TN2Y-A EL-KFR36G/TN2Y-B
Outdoor Models
M2OA-18HRN2 M2OA-21HRN2
M3OA-27HRN2 M3OA-30HRN2
Multi SERIES
Page 1 of 33
2. Specification
3. Dimensions
5. Operation limits
6. Wiring diagram
7. Troubleshooting
8. Electronic function
Page 2 of 33
Page 3 of 33
Page 4 of 33
Page 6 of 33
Panel A
C
D B
Panel B
C
A B
A B C
EL-KFR26G/TN2Y-A(B) 214 750 250
EL-KFR36G/TN2Y-A(B) 217 815 282
Page 7 of 33
Page 8 of 33
“1 drive 3 system” is made up of one “1 drive 1 system” and one “1 drive 2 system”.
PMV1
PMV2
SV2 SV1
2#
T2 1#
T1
Compressor
refrigeration distributor
1 drive 2 system
SV1:Primary four-way valve SV2: Secondary four-way valve PMV1,
PMV2:Electronic expansive valve
T1,T2:Indoor pipe temperature sensor
Condenser
Four-way valve
Evaporator
Compressor
1 drive 1 system
Notice:For 1 drives 2 system, there are two individual refrigerant circuit and two compressors, but for the 1drive 2
system in the 1 drive three system, there is only one refrigerant circuit and only one compressor.
Page 9 of 33
COOLING
17
-7
0 17 32
Indoor air temp. ℃ DB
Note: 1.The chart is the result from the continuous operation under constant air temperature
Condition. However, excludes the initial pull-down stage.
2.The operation range below the dashed is the result added the low ambient kit.
5.2Heating operation
Indoor air temp. ℃ DB
30
25
20
15
10
-5 5 15 25
Outdoor unit air temp.℃ DB
Note : The chart is the result from the continuous operation under constant air
temperature conditions. However, excludes the initial pull-down stage.
Page 10 of 33
Page 11 of 33
Page 12 of 33
Page 13 of 33
Operation Timer
Failure phenomenon
lamp lamp
☆ X Indoor fan speed has been out of control for over 1 minute
On ☆ EEROM error
☆ ☆ No over-zero signal
r Extinguish
☆ Flash at 5Hz
Indoor fan speed has been out of control for over 1 minute ☆ X
Yes No
Yes No
No
Yes
Page 14 of 33
After changing the main control board, check if the failure releases.
Yes
No Yes
The voltage of power supply is too low (less than 187V)? Indoor PCB is defective
Yes No
EEROM error On ☆
No over-zero signal ☆ ☆
This is alarm signal when the main chip can’t detect over-zero signal. When such failure occurs, the main
control board must have fault.
7.2 Outdoor unit
Failure phenomenon LED1 LED2 LED3
Stand by ☆ ☆ ☆
High temp. protect of condenser ☆ ☆
Temp. sensor in condenser 1 is open circuit or short circuit ☆
Temp. sensor in condenser 2 is open circuit or short circuit ☆
☆ Flash at 2Hz
Page 15 of 33
Page 16 of 33
Page 18 of 33
Compressor
ON
ON
4-way Valve
OFF
ON
Outdoor Fan
OFF
Page 19 of 33
Page 20 of 33
Page 21 of 33
No. Part Name Quantity BOM code No. Part Name Quantity BOM code
1 Front panel (type B) 1 2113039184 19 Evaporator temp sensor 1 2230130056
2 Front panel (type A) 1 2113039179 20 Evaporator 1 2153159019
Air cleaner 1 2113010212 21 Bearing holder 1 2273010201
3
Air cleaner holder 1 2113010217 22 Chassis 1 2113031343
4 Air filter 2 2113039175 23 Installation plate 1 2123039002
5 Screw cap 3 2113039178 24 Back cover for chassis 1 2113010216
Window cover for Clamp for connecting
6 repairing 1 2113039183 25 pipe 1 2113010204
Panel frame (type A) 1 2113039176 26 Fan motor 1 2240030005
7
Panel frame (type B) 1 2113039197 27 Cross flow fan, assy 1 2113010219
8 Display board assy 1 2333039081 28 Motor cover 1 2113010203
Holder for display Holder for remote
9 board 1 2113039199 29 controller 1 2113139022
10 Air out frame assy 1 2113039177 30 Remote Controller 1 2335509179
11 Horizontal louver 1 2113039027 31 Transformer 1 2230090029
12 Louver holder I 1 2113031305 32 Cover for E-parts box 1 2113019182
13 Air out frame 1 2113039028 33 Wire joint, 5p 1 2243019081
14 Louver holder II 1 2113031306 34 E-Parts box 1 2113159004
15 Vertical louver 10 2113031365 35 Main control board 1 2135029046
16 Louver motor 1 2240020006 36 Copper nut, TLM-A01 1 2160032000
17 Drain hose 1 2113000001 37 Copper nut, TLM-B02 1 2160032001
18 Indoor temp sensor 1 2243069052
Page 22 of 33
No. Part Name Quantity BOM code No. Part Name Quantity BOM code
1 Front panel (type B) 1 2113159018 19 Evaporator temp sensor 1 2243069051
2 Front panel (type A) 1 2113159016 20 Evaporator 1 2153159020
Air cleaner 1 2113010212 21 Bearing holder 1 2273010201
3
Air cleaner holder 1 2113010217 22 Chassis 1 2113132342
4 Air filter 2 2113132312 23 Installation plate 1 2123050005
Clamp for connecting
5 Screw cap 3 2113132323 24 pipe 1 2113010204
Window cover for
6 repairing 1 2113159005 25 Fan motor 1 2240030213
7 Panel frame 1 2113159015 26 Cross flow fan, assy 1 2110020008
8 Display board assy 1 2333159010 27 Motor cover 1 2113132314
Holder for display Holder for remote
9 board 1 2113159030 28 controller 1 2113139022
10 Air out frame assy 1 2113159007 29 Remote Controller 1 2335509179
11 Horizontal louver 1 2113159031 30 Transformer 1 2230090029
12 Louver holder I 1 2113051554 31 Cover for E-parts box 1 2113139036
13 Air out frame 1 2113159032 32 Wire joint, 5p 1 2230145064
14 Louver holder II 1 2113051555 33 E-Parts box 1 2113139141
15 Vertical louver 11 2113159033 34 Main control board 1 2135029047
16 Louver motor 1 2240020006 35 Copper nut, TLM-A01 1 2160032000
17 Drain hose 1 2110102007 36 Copper nut, TLM-C03 1 2160032002
18 Indoor temp sensor 1 2243069052
Page 23 of 33
9 15
8
12
5 14
4 13
16
6
3 17
2 7
10 11 18
1
19
25 26 27
20 23
45 28 29
21 24
30
22
31
32
36
44 39 33
43
42 41
37 34
40 38 35
Page 24 of 33
Page 25 of 33
9 15
8
12
5 14
4 13
16
6
3 17
2 7
10 11 18
1
19
25 26 27
20 23
46 28 29
21 24
30
22
31
41 32
36
44
45 39 33
43
44
42
43 41
42
37 34
40 38 35
Page 26 of 33
Page 27 of 33
11 12
10
13
9
14
15
6 8
16
7
17
5
25 18
4
19
20
3
21
2
26 35 22
34
33 23
27 36
1 28
37 24
29
30 38
47 39
56
55 46 43 40
45
31
32 53
44 41
42 54
52 51 50 49 48
11 12
10
13
9
14
15
6 8
16
7
17
5
25 18
4
19
20
3
21
2
26 35 22
34
33 23
27 36
1 28
37 24
29
30 38
56 47 39
55 46 43
45 40
31 53
57 32 41
44
42 54
52 51 50 49 48
Page 32 of 33
-4 44 23 10.9731 50 3.451
-2 39.8239 25 10 52 3.1918
Page 33 of 33