Professional Documents
Culture Documents
Auto Wiring Prac & Paper 2
Auto Wiring Prac & Paper 2
1. Draw and wire a circuit of signaling system of a board with hazard switch
THEORY PAPER 2
TIME: 2 ½ HRS
INSTRUCTIONS
1a) With a sketch, show how you can test an ignition coil outside the vehicle.
2a) A resistor is color coded : Red, violet, red and gold.Determine its value and tolerance.
i) Potential Difference
ii) Current
iii) Resistance
iv) Frequency
v) Power
vi) Capacitance
3a) State the relative density of the electrolyte of a lead-acid battery when it is;
i) Fully Charged
ii) Fully discharged
4a) An alternator will not charge when the charge warning lamp has failed . State the reason for
this.
b) State the procedures taken when removing an alternator from the engine.
i) Diode
ii) Rectifier
i) Junction Diode
ii) Zener diode
b) What is the power consumed by a lamp when the rated current and voltage is 2A and 12V
respectively.
c) What is a transducer?
MWEREERWE COMMUNITY VOCATIONAL TRAINING CENTRE
THEORY PAPER 2
TIME: 2 ½ HRS
INSTRUCTIONS
1a) A resistor is color coded; Red, Violet, red and gold. Determine its value and tolerance
i) Potential Difference
ii) Current
iii) Resistance
iv) Frequency
v) Power
vi) Capacitance
2a) What is the power consumed by the lamp when the rated current and voltage is 2A and 12V
respectively?
i) Junction Diode
ii) Zener Diode
c) What is a transducer?
4a) State the relative density of the electrolyte of lead-acid battery when it is;
i) Fully charged
ii) Fully discharged
c) With the aid of a sketch, show how the battery jump start is achieved in a motor vehicle.
5a) An alternator will not charge when the charge warning lamp has failed. State the reason for
this.
b) State the procedures taken when removing an alternator from the engine.
i) Diode
ii) Rectifier
b) With sketch, show how you can test an ignition coil outside the vehicle.
PRACTICAL PAPER
TIME: 2 ½ HRS
INSTRUCTIONS
1a) On the paper provided, draw the starting circuit diagram fully co-operated with a relay,
switch, fuse and present it on the board.
2a) With the paper provide, draw the wiring circuit diagram of a two horns in parallel with relay
fuse and switch.