Professional Documents
Culture Documents
CCNA 3 - Chapter - 2 - Quiz
CCNA 3 - Chapter - 2 - Quiz
CCNA 3 - Chapter - 2 - Quiz
3. A network administrator enters the following command sequence on a Cisco 3560 switch.
What is the purpose of these commands?
Switch(config-if)# no switchport
a.) It provides secure remote WAN access to the head office for teleworkers.
6. A PC is to access a web server on another network. Which inter-VLAN method will provide
the highest bandwidth at Layer 3 and also provide a default gateway for the PC?
7. Which type of VLAN is identified by a VLAN ID between 1006 and 4094 and not contained in
updates of switches participating in a VTP domain?
a.) transparent
b.) native
c.) pruned
d.) extended
8. Which combination of DTP modes set on adjacent switches will cause the link to become an
access link instead of a trunk link?
The switchport parameter can be added to the show interfaces interface_id command
to display the administrative and operational switch interface mode.
10. Refer to the exhibit. Access1 is a new switch that is to be connected as a VTP client to the
network once it has been configured. Given the output generated by the VTP server switch Dist-2,
which series of configuration commands would successfully introduce the client switch into the VTP
domain?
11. Refer to the exhibit. A network administrator has configured router CiscoVille with the
above commands to provide inter-VLAN routing. What type of port will be required on a switch that is
connected to Gi0/0 on router CiscoVille to allow inter-VLAN routing?
d.) SVI
12. Refer to the exhibit. Switch SW2 was tested in a lab environment and later inserted into
the production network. Before the trunk link was connected between SW1 and SW2, the network
administrator issued the show vtp status command as displayed in the exhibit. Immediately after the
switches were interconnected, all users lost connectivity to the network. What could be a possible
reason for the problem?
a.) Switch SW2 is in the wrong VTP operating mode.
c.) Switch SW2 has the pruning eligible parameter enabled, which causes
pruning of all VLANs.
d.) Switch SW2 has a higher VTP revision number, which causes deletion of
the VLAN information in the VTP domain.
13. Refer to the exhibit. A network administrator is configuring RT1 for inter-VLAN routing.
The switch is configured correctly and is functional. Host1, Host2, and Host3 cannot communicate
with each other. Based on the router configuration, what is causing the problem?
a.) Interface Fa0/0 is missing IP address configuration information.
14. Refer to the exhibit. Which option correctly describes the function of a switch that is
configured in VTP transparent mode?
a.) option 1
b.) option 2
c.) option 3
d.) option 4
e.) option 5
d. The IP address and subnet mask are wrongly configured for VLAN 20.