The document summarizes modifications made to the project design. The body frame material was changed from mild steel to carbon steel due to availability and cost. The leg material was changed to angle bar for balance and the leg support to steel plate bar due to availability. The angle grinder bearing base was modified to a bull bearing with housing for availability and cost. Bolt sizes were increased from 6mm and 8mm to 10mm for machinability. The upper mesh height was decreased from 5mm to 3mm to reduce unnecessary space and improve machinability.
The document summarizes modifications made to the project design. The body frame material was changed from mild steel to carbon steel due to availability and cost. The leg material was changed to angle bar for balance and the leg support to steel plate bar due to availability. The angle grinder bearing base was modified to a bull bearing with housing for availability and cost. Bolt sizes were increased from 6mm and 8mm to 10mm for machinability. The upper mesh height was decreased from 5mm to 3mm to reduce unnecessary space and improve machinability.
The document summarizes modifications made to the project design. The body frame material was changed from mild steel to carbon steel due to availability and cost. The leg material was changed to angle bar for balance and the leg support to steel plate bar due to availability. The angle grinder bearing base was modified to a bull bearing with housing for availability and cost. Bolt sizes were increased from 6mm and 8mm to 10mm for machinability. The upper mesh height was decreased from 5mm to 3mm to reduce unnecessary space and improve machinability.
Table 1.1 below shows the modifications done by the researchers to the project design due to significant reasons.
PARTS MODIFICATIONS MADE REASON/S:
Body Frame Proposed Material: Availability of
Mild Steel Materials
Modifications Made: Cost
Changed the Material from Mild Steel into Carbon Steel Suggested by (the same dimensions) the Welder
Legs and Leg Support Proposed Material: Suggested by
Mild Steel the Welder to Effectively For the Legs: Sustain the Changed Mild Steel into Balance while Angle Bar (1 in x1 in, 5mm Vibrating thickness) Availability of For the Leg Support: Materials Changed the Material from Mild Steel into Steel Plate Bar (35 in x 1 in, 3 mm)
Angle Grinder Bearing Base Modifications Made: Availability of
Changed Angle Bearing Materials Base to Bull Bearing w/ Housing Cost
Bolts and Nuts Proposed Dimension:
6mm and 8 mm Machinability Modifications Made: 10mm
Upper Mesh Proposed Dimension of the Machinability
Upper Mesh: h = 5 mm Takes a lot of unnecessary Modification Made: space Adjusted its height, from h = 5mm into h = 3mm