Professional Documents
Culture Documents
1253 (5) Disassembly
1253 (5) Disassembly
DISASSEMBLY INSTRUCTIONS
ƒRBe sure to unplug the machine out of the outlet before disassembling and repairing the parts.
CONTROL PANEL
PANEL ASSY(CONTROL)
PWB ASSY(DISPLAY) ¤ Disconnect the PWB assy (Display) from the control
panel by unscrewing 9 screws.
25
DISPENSER ASSY
DRAWER
DISPENSOR ASSY
26
INLET VALVE
VALVE#3(HOT) Blue/Red-Black
¡aWD-1253FH / WD-1255FH¡b
PWB ASSY(MAIN)
27
DOOR
GASKET ASSY
¤ Take apart the cabinet gasket clamp.
¤ŁUnscrew 2 screws from the cabinet cover.
¤ØOpen the lower cover cap and unscrew 1 screw inside
¤ŒTake apart the lower cover
28
PULLEY, MOTOR, DAMPER
(PULLEY)
¤ Unscrew 2 screws from the bracket.
¤ŁPush the motor in the arrow direction for
disassembling.
¤ØWhen reassembling the motor, make sure that motor
1 mounting rubbers are not taken off from the bracket.
2
3
(MOTOR)
(DAMPER)
1 2
3 2
Open the lower cover cap ( ¥L ) Unplug the drain plug ( ¥M) , then from the pump filter ( ¥N). After
by using coin. the water flows out, cleaning, turn the pump filter(¥N)
At this time use a vessel clockwise and insert the
to prevent water flowing on the drain plug ( ¥M)to the original
floor. If the water does not flow any place. close the lower cover cap.
more,turn the pump filter ( ¥N)
open to the left.
Take out any foreign material
29
PUMP
¤ Remove pump outlet hose.
Pump Outlet Hose
¤ŁRemove tub pump bellows.
¤ØRemove cap(Remaining Hose.)
¤ŒDisconnect the wiring.
Screw
¤ºUnscrew 3 screws
¤ Remove the pump.
Cap
(Remaining Hose) Tub Pump Bellows
HEATER
¤ Unscrew 3 screws fixing the heater protecting cover.
¤ŁLoosen the M6 heater nut to pull out the heater.
CAUTION
When mounting the heater, be sure to insert the heater
into the heater clip on the bottom of the tub.
THERMISTOR
¤ Pull it out by holding the thermistor bracket.
ƒTIf it is pulled by the wire, it may be broken.
¤ŁWhen mounting the thermistor again, make sure that it
is got back tight to the rubber.
30
DOOR HINGE ASSY
31