Professional Documents
Culture Documents
Rabee Incubator
Rabee Incubator
Rabee Incubator
■■ Main body
Symbol Name and meaning Symbol Name and meaning
WEEE symbol
General attention
In the EC area, an electrical and
Indicates unspecified general danger,
electronic product falling in one of the
warning or caution.
categories specified by “DIRECTIVE
Caution: Hot surface 2002/96/EC OF THE EUROPEAN
PARLIAMENT AND OF THE COUN-
Indicates that the surface can be CIL of 27 Januar y 2003 on Waste
dangerously hot under certain con- Electrical and Electronic Equipment
ditions. (WEEE)” should be disposed of in a
manner consistent with relevant laws
Detaching procedure of the
and regulations.
humidity chamber
This symbol indicates that the above-
Pull the humidity chamber cover mentioned requirement applies to
down to the position shown in the this product.
figure on the left.
Date of manufacture
raw out the humidity chamber
D
until it stops halfway. Lift up the Indicates the date when the unit was
humidity chamber slightly and manufactured in the factory.
remove from the unit.
Product version
Installation procedure of the
humidity chamber Indicates the product version.
■■ Control panel
Symbol Name and meaning Symbol Name and meaning
Alarm silenced
Setting up
Indicates either a control switch to
Indicates that a setting is increased.
silence the bell temporarily, or that
the bell is silenced.
Setting down
Skin temperature probe alarm
Indicates that a setting is decreased.
Indicates that the skin temperature
probe is faulty or has been short-
circuited. Incubator air circulation
Indicates the function related to air
Set temperature alarm circulation in the incubator in the
(1) In the servo control mode: incubator mode or that the incubator
Comes on when a detected skin is in manual control.
temperature deviates from the set
temperature by 1°C or more. Setting
(2) In the manual control mode: Indicates set values or the setting
procedure.
Comes on when a detected incu-
bator air temperature deviates
from the set temperature by 3°C Skin temperature
or more. Indicates the function related to the
infant’s skin temperature or that the
High temperature alarm
incubator is in servo control.
Is displayed when a detected incubator
air temperature deviates from the set
Low water level
temperature by 1°C or more.
Indicates that the water level in the
(1) In the servo control mode or in
humidity chamber is low.
the manual control mode with
the override mode function on:
40°C No water
(2) In the manual control mode with Indicates that there is no water in the
the override function off: 38°C. humidity chamber.
Mains on
Indicates that the device is connected
to AC power.