Download as docx, pdf, or txt
Download as docx, pdf, or txt
You are on page 1of 2

……………..

Team FORMULATOR

Daily Practice Set (Electrical Engg) for SSC JE & RRB JE


SET-01
1. In a series RL circuit, 12 V rms is measured across the resistor, and 14 V rms is measured
across the indicator. The peak value of the source voltage is
A. 18.4 V
B. 26.0 V
C. 2V
D. 20 V

2. The induced voltage across a coil with 250 turns that is located in a magnetic field that is
changing at a rate of 8 Wb/s is
A. 1,000 V
B. 2,000 V
C. 31.25 V
D. 3,125 V .

3. When the current through the coil of an electromagnet reverses, the


A. direction of the magnetic field reverses
B. direction of the magnetic field remains unchanged
C. magnetic field expands
D. magnetic field collapses .

4. When the pointer of an analog ohmmeter reads close to zero, the resistor being measured
is
A. overheated
B. shorted
C. open
D. reversed

5. A power supply produces a 0.6 W output with an input of 0.7 W. Its percentage of efficiency
is
A. 8.57%
B. 42.85%
C. 4.28%
D. 85.7%

Add: FORMULATOR campus, 1st floor, opp NMCH, near railway line crossing, Bazar samiti road, Patna
Mob: 8539965784/ 7277084298
6. In a certain parallel resonant band-pass filter, the resonant frequency is 14 kHz. If the
bandwidth is 4 kHz, the lower frequency
A. is 7 kHz
B. is 10 kHz
C. is 12 kHz
D. cannot be determined .

7. A 2 mH, a 3.3 mH, and a 0.2 mH inductor are connected in series. The total inductance is
A. 55 mH
B. less than 0.2 mH
C. less than 5.5 mH
D. 5.5 mH

8. If the RC time constant of an integrator is increased, as the time constant is increased


A. the capacitor charges more during a pulse and discharges less between pulses
B. the capacitor charges less during a pulse and discharges more between pulses
C. the capacitor charges more during a pulse and discharges more between pulses
D. the capacitor charges less during a pulse and discharges less between pulses

9. Determine VTH when R1 is 180 Ω and XL is 90 Ω.


A. 13563.4° V
B. 13.563.4° V
C. 12.20° V
D. 1220° V.

10. For the circuit shown, determine ZTH for the portion of the circuit external to RL.
A. 66.7 –33.7° k
B. 6.67–333.7° k
C. 14.4 –56.3° k
D. 1.44 –33.7° k

Add: FORMULATOR campus, 1st floor, opp NMCH, near railway line crossing, Bazar samiti road, Patna
Mob: 8539965784/ 7277084298

You might also like