Professional Documents
Culture Documents
Assignment 4.1 (Practice Set 6)
Assignment 4.1 (Practice Set 6)
Practice Set 5
Assignment 4.1 Network Configuration
Score
Leader:
<LN, GN MI >
Members:
Amante, Alexander Adrian R.
Baldridge, Dale Nigel O.
De Gracia, Marc Renz A.
Delos Santos, John Alfred D.
Eballar, John Haru
Llanes, Khyle Danielle I.
Luceño, Janrey D.
IT31S1
2. Discussion
-Computers that specialize in sending packets over the data network. They are
responsible for interconnecting networks by selecting the best path for a packet to travel
and forwarding packets to their destination
▪ Routers examine a packet's destination IP address and determine the best path
by enlisting the aid of a routing table
▪ Router components and their functions."
▪ CPU - Executes operating system instructions
▪ Random Access Memory (RAM) - Contains the running copy of the
configuration file. Stores routing table. RAM contents lost when power is
off
▪ Read-only memory (ROM) - Holds diagnostic software used when the
router is powered up and stores the router's bootstrap program.
▪ Non-volatile RAM (NVRAM) - Stores startup configuration. This may
include IP addresses (Routing protocol, Hostname of the router)
▪ Flash memory - Contains the operating system (Cisco IOS)
▪ Interfaces - There exist multiple physical interfaces that are used to
connect networks. Examples of interface types:
▪ -Ethernet / Fast Ethernet interfaces
▪ -Serial interfaces
▪ -Management interfaces
3. Requirements
Router Commands:
A. Enter the privileged mode, use the following command:
⮚ Router>enable or en
This changes the prompt to "Router#." The privileged mode prompt always ends with
"#."
Note:
● Use the "ping" command to determine if both devices are connected.
● The "Ping" command will help you to determine if your network connection is completely
failed.
● As shown above, if you ping the other host IP address (192.168.10.5) success rate must
be 100 percent; otherwise, if 0 percent, you have a problem to your network
configuration or IP address configuration.
5. Use the "traceroute" command to determine the number of hops from the source to the
destination address.
Note:
● Use traceroute for displaying the route (path) and measuring transit delays of packets in
the Internet Protocol network.
● The command is "traceroute host IP address" (traceroute 192.168.10.5), as shown
above.
6. Use the "show IP route" command to see the neighboring routers.
Note:
● Type "show IP route host IP address" (show IP route 192.168.10.5) to show the routing
table.
You will also identify where is currently directly connected to your networking device.
5. Group Observation
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
6. Individual Synthesis
<Name 1>
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
<Name 2>
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
<Name n>
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
Instruction: