Professional Documents
Culture Documents
Aluminum Drum Set-Up
Aluminum Drum Set-Up
Aluminum Drum Set-Up
Remove the lid from the drum. Remove the wire tie on the plastic bag and Remove the wood slats and release the
then pull the bag down over the drum. rubber bands to the bottom of the drum.
1 2
Center the rubber bands in the bottom of the Grasp the end of the wire and hold onto it 1– Clip the loop from the end of the
drum. Any object/waste left in the bottom of while removing and discarding the cardboard wire and insert the Top Hat Spinner
the drum may cause tangles. ring. Pressure should be applied device in the drum.
to the wire to prevent it from springing out 2– Thread the wire into the device.
of the drum.
Clip the loop from the end of the wire and Remove any burrs or flashing in the orange Thread the wire into the Drum Tube Connector
place the clear plastic ring on top of the wire drum tube and connect it to the feeder and the Kit/drum tube and the orange conduit. The
drum. The edges of the plastic ring must be Drum Tube Connect Kit. drum tube (orange tube 418750-005) should
pointing up and the wire must feed through the protrude ¼" below the Drum Tube Connect Kit
center of the ring for proper payout. (418750-004).
STEP 9
12"
Components Needed:
E F G 300 & 100 lb
MAXALPAC Drum
1XXX & 4XXX
A, B (2x), C, E, G
alloys