Professional Documents
Culture Documents
Nov 2006) - Elex
Nov 2006) - Elex
Manila
Macro Integrated Training and Review Center
INSTRUCTION: Select the correct answer for each of the following questions. Mark only one answer for each item by
shading the box corresponding to the letter of your choice on the answer sheet provided.
STRICTLY NO ERASURES ALLOWED. Use pencil no. 2 only
2. What is considered as the darkest horse that emerged in computer designs and sometimes dubbed as the ultimate
computer?
a. Power computer b. CRAY-1 computer
c. Quantum computer d. ABC computer
4. A tank circuit is a
a. Parallel LC circuit b. Resonant circuit
c. Series LC circuit d. Non-resonant circuit
5. The open circuit voltage at the terminals of a load RL is 100 V. Under the condition of maximum power transfer, the
load voltage will be ___.
a. 100 V b. 70.7 V
c. 200 V d. 50 V
6. What term means the rate of measurement of how successful a user is when carrying out a research in a database?
a. bitrate b. ditrate
c. hitrate d. jetrate
7. The process by which an emf and hence current is generated or inducted in a conductor when there is a change in
the magnetic flux linking the conductor is called
a. Electromagnetic induction b. Mutual induction
c. Faraday’s Law d. Electromagnetic interference
8. Whenever a conductor cuts magnetic flux, an emf is induced in it. This is known as
a. Coulomb’s law b. Joule’s law
c. Faraday’s law c. Ohm’s law
10. Approximately, how many transistors can be crammed in a chip in the year 2015 according to Moore’s law
prediction?
a. 1 million b. 1 billion
c. 10 billion d. 100 trillion
11. Which of the following materials has permeability slightly less than that of free space?
a. Paramagnetic b. Non-magnetic
c. Ferromagnetic d. Diamagnetic
12. What is one of the most indigenous ideas treating the double stranded molecule as a kind of biological computer
tape?
a. RNA computer b. Molecular computer
c. Cellular computer d. DNA computer
13. The amount of magnetizing force to counter balance the residual magnetism of a magnetic material is referred to as
a. Reluctivity b. Susceptivity
c. Coercivity d. Retentivity
14. The lagging effect between flux density of the material and the magnetizing force applied.
a. Permeance b. Eddy current
c. Hysteresis d. Reluctance
MITRC 1 jam
15. What is the thin plastic card with a large amount of information on it.
a. micropist b. microplastic
c. microfiche d. External modem
17. The force between two magnetic poles is _____ their pole strength.
a. Equal to b. Directly proportional to
c. Inversely proportional to d. Directly proportional to the square root of
19. A length of wire has a resistance of 10 . What is the resistance of a wire of the same material three times as long
and twice the cross-sectional area?
a. 30 b. 20
c. 15 d. 7
20. The electric potential at a point in air due to a charge is 21 V. If air is replaced by a medium of relative permittivity of
3, then electric potential at that point will be
a. 63 V b. 21 V
c. 7 V d. 42 V
21. What alloy of nickel used in thermostats with low or zero thermal expansions?
a. manganin b. constantan
c. invar d. nikolai
22. Essentially power electronics deals with the control of ac power at what frequencies?
a. 20 kHz b. 1000 kHz
c. Less than 10 Hz d. 60 Hz
23. A control system in which the output is related to the input by device parameters only.
a. Open loop control system b. Closed loop control system
c. Servomechanism d. Feedback control system
28. A 0.09 μF capacitor is charged to 220 V. How long in milliseconds will it discharge to a level of 110 V if the discharge
resistor has a resistance of 20, 000 ?
a. 1.5 b. 2.5
c. 1.25 d. 0.5
29. The resonance curve is a plot of frequency versus ____ for a series RLC circuit.
a. Current b. Voltage
c. Gain d. Impedance
30. “Any resistance R in a branch of a network in which a current I is flowing can be replaced by a voltage equal to IR”.
This states
a. Compensation theorem b. Reciprocity theorem
c. Millman’s theorem d. Superposition theorem
31. In what computer design in which the silicon transistor is replaced with a single molecule and a single electron
a. Biological computers b. DNA computers
c. Molecular and dot computers d. Electron computers
MITRC 2 jam
33. What op-amp is considered as the industry standard?
a. LM741C b. LM741A
c. LM722C d. TO225C
34. An inductive circuit of resistance 16.5 and inductance of 0.14 H takes a current of 2.5A. If the frequency is 50 Hz,
find the supply voltage.
a. 45 V b. 117.4 V
c. 120 V d. 448 V
36. A three-by-three, series-parallel matrix of resistors, all having the same ohmic value, would have a net resistance of
a. 1/3 the value of a single resistor b. Three times the value of a single resistor
c. The same value as a single resistor d. Nine times the value of a single resistor
37. What is the value of a carbon composition resistor with the following color code: Brown, White, Orange, Red
a. 190 ; 10% b. 19 k; 2%
c. 19 k; 20% d. 1.8 k; 2%
38. The power factor of a certain circuit in which the voltage lags behind the current is 80%. To increase the power
factor to 100%, it is necessary to add __________ to the circuit.
a. Inductance b. Capacitance
c. Resistance d. Impedance
39. An inductor carries 2A dc. If its inductance is 100 mH, then what is its inductive reactance?
a. Zero b. 37.7
c. 6 d. Cannot determine due to lack of data
41. What is the small fuse containing a spring which upon release by the fuse wire completes an auxiliary circuit to
operate an alarm?
a. Grasshopper fuse b. Beefuse
c. Butterfly fuse d. snakefuse
42. What computer design in which the idea is in direct laser or radio beam on a carefully arrange connection of atomic
nuclei each of which is spinning line on top
a. Nuclear computer b. ASG computer
c. DNA computer d. Quantum computer
44. When the emitter junction is forward biased while the collector junction is reverse biased, the transistor is at ______
region.
a. cut-off b. saturation
c. active d. breakdown
45. What is the mechanism used for reading and writing data on a disk?
a. Access arm b. pit
c. Access feet d. leptons
47. The removal by electronic means of one extremity of an input waveform is called ___________.
a. filtering b. clamping
c. amplifying d. clipping
4 8 . A varistor is used for line filtering to eliminate spikes and dips and is also called a ___.
a. transient regulator b. transient limiter
c. transient filter d. transient suppressor
4 9 . A class ________ amplifier stage operates with a small forward bias on the transistor so that some collector current
flows at all times.
a. A b. B
c. AB d. C
MITRC 3 jam
51. The purpose of DC conditions in a transistor is to ___
a. Reverse bias emitter b. Set up the operating point
c. Forward bias emitter d. None of the above
53. IC consisting of 200 logic gates of greater than 64000 bits of memory is_________
a. LSI b. VLSI
c. SSI d. ULSI
54. If the input capacitor of a transistor amplifier is short circuited, the _____
a. Biasing conditions will change b. Transistor will be destroyed
c. Signal will not reach the base d. None of the above
55. In obtaining the frequency response curve of the amplifier, the _____.
a. Generator output level is kept constant b. Amplifier output is kept constant
c. Generator frequency is held constant d. Amplifier is frequency is held constant
56. What refers to a method in which charger and a battery are always connected to each other
for supply current to the load?
a. Fast charge b. F l o a t c h a r g e
c. S l o w c h a r g e d. F l y c h a r g e
59. The total gain of the multistage amplifier is less than the product of the gains of individual
stages due to _____
a. Loading effect of the next stage b. The use of many transistors
c. Power loss in the coupling device d. The use of many capacitors
61. What is the ratio of the ion current in a tube to the electron current produces it?
a. S o l i d r a t i o b. L i q u i d r a t i o
c. Gas ratio d. P l a s m a r a t i o
64. When two frequencies are mixed in a non-linear circuit, then _____ distortion results
a. Frequency b. Amplitude
c. Intermodulation d. None of the above
65. When the voltage feedback (negative) is applied to an amplifier, it input impedance _____
a. Is decreased b. Becomes zero
c. Is increased d. Remains the same
67. What is the gas inside the inner discharge of tube of a sodium vapor lamp?
a. a r g o n b. neon
c. k r y p t o n d. o x y g e n
MITRC 4 jam
68. The output impedance of an emitter follower is _____
a. Low b. High
c. Very high d. Almost zero
74. Quartz crystal is most commonly used in crystal oscillators because _______
a. It is easily available b. It has superior electrical properties
c. It is quite inexpensive d. None of the above
77. What do you call the standard message used for testing teletypewriter circuits and machines
because it includes alphanumeric?
a. T e x t m e s s a g e b. D o g m e s s a g e
c. F o x m e s s a g e d. C a t m e s s a g e
78. Which of the following dry cells has the largest height?
a. D b. C
c. AAA d. AA
80. The name given to that property of a material which opposes the creation of magnetic flux in it.
a. Resistance b. Reluctance
c. Conductance d. Permeance
83. What user programs that has the ability to move a robot axis to any position within its range?
a. Point-to-point b. Positive stop
c. Continuous path d. Pick and place
MITRC 5 jam
86. Term for the phenomenon, which occurs in electrical circuits when the inductive reactance
equals the capacitive reactance.
a. High Q b. Reactive Quiescent
c. Reactive Equilibrium d. Resonance
89. It is the reciprocal of reluctance and implies the case or readiness with which magnetic flux is
developed.
a. Resistance b. Remanence
c. Conductance d. Permeance
90. __________ is that force which sets up or tends to set-up magnetic flux in a magnetic circuit.
a. Electromotive force b. Potential difference
c. Magnetomotive force d. Dynamic force
91. What refers to the time for a disk to spin a particular place under the head reading?
a. S p i n d l e t i m e b. D i s k t i m e
c. L a t e n c y t i m e d. H e a d - r e a d i n g t i m e
92. A circuit which provides a means of isolating an input from a load using a stage having unity
voltage gain and with no phase in polarity inversion is called _________.
a. Voltage buffer b. Inverting op-amp
c. Voltage summing d. Non-inverting op-amp
94. What is the property of the magnetic circuit that resists the establishment of flux?
a. Reluctance b. Permeance
c. Inductance d. Mutual inductance
95. What is the weakest signal that produces a usable signal at the output of a receiver?
a. Max Discernible Signal b. Minimum Discernible Signal
c. Tolerable Discernible Signal d. Sensitivity
96. How do you describe materials whose permeability’s are a little greater than that of free space?
a. Paramagnetic b. Ferromagnetic
c. Diamagnetic d. Non-magnetic
99. What welding type allows two metal plates to be weld provide sufficient surface contact
resistance when passing current from the welding electrodes?
a. S p o t w e l d i n g b. s o l d e r i n g
c. D o m i n o w e l d i n g d. B a c k s t r o b e w e l d i n g
MITRC 6 jam