Professional Documents
Culture Documents
Cat. Filtro - Emerson - Tipo y
Cat. Filtro - Emerson - Tipo y
900 SERIES
Protecting pipeline components from damaging particles with minimal pressure drop
FEATURES
Yarway wye type strainers are suitable for Size range: NPS ⅜ to 2 (DN 10 - 50)
use in a variety of fluid systems such as air,
chemical, condensate, gas, oil, petroleum
or water lines, for the protection of valves,
pumps, compressors, condensers, flow meters,
nozzles, steam traps and other vulnerable
equipment.
There are three important components in Strainers should be installed upstream of Body shall be wye-type. Threaded cap shall
selection: pipeline equipment to protect against damage have straight machined threads for easy
1. Design and operating pressures and from solid particles of dirt, chips, scale, packing removal. Body and cap shall have machined
temperatures - look at the curves in shreds, pipe sealants and welding debris. surfaces for metallic clad, non-asbestos
Figure 2. Select the strainer rating that The strainer should be fitted with a pipe nipple gaskets. Strainer screen shall fit into
meets both the design and the operating in the cap and a full ported straight through non-tapered machined bores. Thread end
requirements. valve (e.g., gate or ball). strainers hall be machined to ASME B1.20.1.
2. Flow rate and pressure drop - select Install the strainer in a horizontal or vertical Socketwelding ends shall be to ASME B16.11;
a strainer pipe size that will yield a line with flow in the direction of the arrow. flanged ends shall conform to ASME B16.4
pressure drop of 1½ psi or less. This will For freeze protection, install the strainer on (iron) or B16.5 (steel).
accommodate increases in pressure drop its side or upside down in a horizontal line or
due to dirt or alternate screens without vertically to assist in draining the blowdown line
causing the screen to rupture. and strainer cavity. HOW TO ORDER
3. Look at the selection table on page 4 Inspect the strainer regularly. Clean the
and pick the strainer series that meets screen before it becomes more than one-third Specify pipe size, Yarway series and pipe
the conditions of 1 and 2 above, and is clogged. Pressure gages before and after the connection. Example: ¾", Yarway series 921,
compatible with the flowing medium. strainer will indicate excessive pressure losses NPT ends.
due to clogging.
2
YARWAY WYE-TYPE PIPELINE STRAINERS
900 SERIES
NOTES
1. See Chart, Figure 2 for pressure/temperature ratings.
2. See page 7 for optional screen materials and openings.
.5 1 2 5 10 20 50 10 200 500
10
9
8
7 .5
900
6 .4
900
900
”-
900
5
00
900
,½
.3
"-
-9
"-
-
4
-
⅜"
1¼
¾"
1½
2"
1"
3 .2
Cv .1
1.0
.9
.8
.7 .05
.6
.04
.5
.03
.4
.3
.02
.2
.01
.1
1 2 3 4 5 6 7 8 9 10 2 3 4 5 6 7 8 9100 2 3 4 5 6 7 8 9 1000 2 3
3160 VI
50,000 2
∆Ps ∆Ps
= = 1.63
(115) -
are based on new, clean strainers. If clogged 4 will predict a greater than expected pressure number for 150 gpm flow in the example is:
2 (2000) (1 + 0.0007
(2.1) (55)
x 162)
2
Equation
∆Pv 2:
= (1.6023)(0.82) GI - (963) (Cv)
What is the Cv for a 2" 900 Yarway Wye strainer? Equation 3: 56 =11.46 psi 1 (2.1) (Cv)
Equation 3:
Solution:
3160Equation
VI 4:
1. Enter the left, vertical axis at one (1.0) psi. Cv ∆Pv 50,000 2
VI = vd ∆Pg = (115) - (115)2 - (0.667) (560)
2. Move horizontally to the right until you reach GI (963) (55)
( Cv ) ∆Pv
the 2" 900 curve. (3160) 4000 (150)
= (3160)
GI = Specific gravity vdof liquidGI Equation 6
3. Then, move vertically down and read 56 gpm. (2.69) Equation 3:
(3.068) = 1.46 psi
Equation 4:
∆Pv = Viscous fluid, pressure drop, psi
4. Answer - The Cv for a 2" 900 is 56.
d = Pipe I.D. inch
This solution is for water; specific gravity is Cv ∆Pv ( Cv ) ∆Pv (Q) 2
4000 VI = =
(3160) ∆Pg = P1 - (P1)2 - (G) (T)
approximately one. GIvd (963) (Cv)
Equation 5 Equation
Combining 2GIand 23 and assuming
Re = ∆Pv 4000=minimum (vd)
for turbulent flow, and 'd'
(1.6023)(GI)
is a controlling Cv strainer:
Equation 4: factor for the
Liquid flow with specific gravity not equal to one (W) (1 + 0.0007 equations.indd
Ts )
2
1
∆Ps = P1 - (P1) -
2
Example:
( Cv ) 2 ∆Pv (2.1) (Cv)
What is the pressure drop if the fluid is 4000 = (3160) (vd)
∆Pv = (1.6023)(GI) vd GI
kerosene, flowing at 150 gpm for a 2" 900 Equation 4: Cv equations.indd 1
strainer?
Solution: (2.69 x 3.068)2
Equation ∆Pv 6= (1.6023)(0.82)
1. Enter a table of various liquids. 56
2. Find kerosene with a specific gravity of 0.82. Equation 4: (vd)2
∆Pv = (1.6023)(GI)
3. Solve the equation Cv (Q) 2
(W) (1 + 0.0007 Ts )
2
∆Ps = P1 - (P1)2 -
Equation 5 (2.1) (Cv) 4
(3160) (150)
(2.69) (3.068)
(W) (1 + 0.0007 Ts )
2
∆Ps = P1 - (P1)2 -
(2.1) (Cv)
Equation 6
Equation 4:
∆Ps==1.31
(115) - drop (2000) (1 + 0)
is 2100 psig, saturated. What is the pressure From equation 5 (115)
2
∆Ps = 1.31
(115)psi- drop(115)2
VFrom
I to 11/2=psi.
2
Figure 1 we see that the 2" 921 has a Cv (2.1) (55)
∆PI = G 2
EquationC1: equal
v to 55. ∆Ps = (115) - (115)2 (2000) (1 + 0.0007 x 162)
=[0.82](150/56)^2 = 5.88 psi (2.1) (55)
P1 = 100 psig = 115 psia equations.indd 1
= 1.31 psi drop
VW I = 2000 lb/h
2
2
∆PI = G
CCv = 55= 5.88 psi
∆Ps
∆Ps= =1.63
equations.indd 1
(115)psi- (115)2 (2000) (1 + 0.0007 x 162)
=[0.82](150/56)^2
v (2.1) (55)
Equation 2:Ts = 0, because the steam is saturated
∆Ps = 1.63 psi 2
Cv GASES
∆Pv
( Cv ) ∆Pv Pressure drop is approximately 1½ psi.
VI = =(3160)
4000
Equation 4: GI
vd GI
If we keep the same strainer, but now consider
(C ) ∆Pv
4000 = (3160)naturalv gas flow at 50,000 SCFH and at a
Equation 4: vd GI
temperature of 100°F.
Cv = 55
( Cv ) 2 ∆Pv
4000 = (3160)
∆Pv = (1.6023)(GI) vd(vd)
P1 = 115 psiaGI
G = 0.667 Cv
T = 460(vd)
+ 100
2 = 560R
∆Pv = (1.6023)(GI)
Q = 50,000 Cv
Equation 4: (vd)2
∆Pv = (1.6023)(GI)
Cv
(2.69 x 3.068)2
∆Pv = (1.6023)(0.82)
Equation 4:
56
(2.69 x 3.068)2
∆Pv = (1.6023)(0.82)
Equation 4: 56
6
YARWAY WYE-TYPE PIPELINE STRAINERS
900 SERIES
3000
200
Prolonged exposure not
System design pressure psig (non-shock)
2000
921, 921SW
1500 600 psi CS 100
1000
921,
921SW 50
500
901, 250 psi CI
0 0
0 100 200 300 400 500 600 700 800 900 1000
SCREEN EQUIVALENT
Perforations Approximate Equivalent
Diameter Number of perf.
NPS (mm) per square inch Mesh Fraction (in.)
0.020 (0.51) 625 42 1/64
0.125 (3.18) 33 8 ⅛
0.0052 (0.13) 20 x120 Dutchweave 100 -
7
YARWAY WYE-TYPE PIPELINE STRAINERS
900 SERIES
SCREENS
Neither Emerson, Emerson Automation Solutions, nor any of their affiliated entities assumes responsibility for the selection, use or maintenance of any product.
Responsibility for proper selection, use, and maintenance of any product remains solely with the purchaser and end user.
Yarway is a mark owned by one of the companies in the Emerson Automation Solutions business unit of Emerson Electric Co. Emerson Automation Solutions,
Emerson and the Emerson logo are trademarks and service marks of Emerson Electric Co. All other marks are the property of their respective owners.
The contents of this publication are presented for informational purposes only, and while every effort has been made to ensure their accuracy, they are not to be construed
as warranties or guarantees, express or implied, regarding the products or services described herein or their use or applicability. All sales are governed by our terms and
conditions, which are available upon request. We reserve the right to modify or improve the designs or specifications of such products at any time without notice.
Emerson.com/FinalControl