Professional Documents
Culture Documents
Asmoro 2021
Asmoro 2021
*Email: prayogoasmoro@apps.ipb.ac.id
Abstract. Refugia plants can support the biological control of plant pests by
increasing the presence and fitness of parasitoids. One of the factors that determine the
suitability of refugia plants with parasitoids is the flower morphology. This study
used Diadegma semiclausum, a parasitoid of cabbage pest, Plutella xylostella. This
study aimed to determine the effect of refugia plants' flower morphology on the
longevity of D. semiclausum adults. Refugia plants used were Rorippa
indica, Brassica rapa, Ageratum conyzoides, and Sphagneticola trilobata. Research
methods consist of insect rearing and plant preparation, testing refugia flowers'
influence on parasitoid longevity, and measuring flower morphology (corolla length
and aperture, and nectar location). The results showed all refugia flower treatments
could increase the parasitoid longevity compared to control (1.71-3.69 times). The
best effect was demonstrate by the R. indica treatment, followed by B. rapa, A.
conyzoides, and S. trilobata. Correlation and regression analysis showed that the
increasing corolla aperture and length positively affected parasitoid longevity. Flowers
with exposed nectar positions (R. indica and B. rapa) makes the parasitoid easy to
access, even though the corolla flowers were longer than A. conyzoides and S.
trilobata.
1. Introduction
Biological control has been widely developing as pest control that is environmentally friendly and has
a low negative impact. One example of the application of biological controls is controlling the
diamondback moth Plutella xylostella L. (Lepidoptera: Yponomeutidae) using the
parasitoid Diadegma semiclausum Hellen (Hymenoptera: Ichneumonidae). The parasitization rate of
D. semiclausum against P. xylostella was relatively high, ranging from 70% -94% [1]. However,
several studies have shown that the parasitization rate of D. semiclausum fluctuates and tends to be
low under certain conditions [2][3]. The intensive use of insecticides, monoculture cultivation, and
insufficient understanding to conserve natural enemies caused the decrease of biological control
effectivity.
Modifying habitat or ecosystem can improve the continuity of biological control. Habitat
engineering can be done by planting refugia plants around cultivated plants. Refugia plants can act as
Content from this work may be used under the terms of the Creative Commons Attribution 3.0 licence. Any further distribution
of this work must maintain attribution to the author(s) and the title of the work, journal citation and DOI.
Published under licence by IOP Publishing Ltd 1
International e-Conference on Sustainable Agriculture and Farming System IOP Publishing
IOP Conf. Series: Earth and Environmental Science 694 (2021) 012049 doi:10.1088/1755-1315/694/1/012049
a source of nutrition for natural enemies. The existence of refugia plants has a positive effect on
natural enemies of pests [5]. The presence of flowering plants can have a positive effect on natural
enemies [6][7][8][9]. Centaurea cyanus (Asteraceae) could attract and provide nectar for the
Microplitis mediator (Hymenoptera: Braconidae). On the other hand, the flower can increase the
parasitism rate of the cabbage moth Mamestra brassicae (Lepidoptera: Noctuidae) [10].
The increased level of parasitization of Cotesia rubecula, Diaeretiella rapae, and Copidosoma
koehleri is closely related to the presence of nectar-producing plants [11][12][13]. Several types of
spiders are also known to consume nectar [14]. Pollen, nectar, and extrafloral nectar of flowers can
increase longevity, reproductive capacity, predators, and parasitoid ability to control insect pests. The
availability of nectar also increased the average reproductive life of the parasitoid Diadegma
semiclausum from 1.2 days (control) to 28 days [15].
The longevity of the parasitoid Copidosoma aretas Walker (Hymenoptera: Encyrtidae) was 1.4
times longer in Fagopyrum esculentum Moench (Polygonaceae) plants compared to controls. The
average length of life for D. semiclausum fed on F. esculentum was 30.3 days (male) and 25.6
(female) compared to water [6]. The longevity of the Diaeretiell rapae McIntosh (Hymenoptera:
Braconidae) could increase 3.4 times with feed sources Leptospermum sp., D. semiclausum increased
4.3 times with Myoporum parvifolium as feed sources, and Cotesia glomerata (Hymenoptera:
Braconidae) increased by 6.9 times with a feed source of Grevillea sp. [16].
Exploring and selecting refugia plants is the earliest stage determining pest control's success
[17][18]. Refugia plants used for habitat engineering need to be chosen to maximize their role as a
source of nutrition for natural enemies. The successful use of nectar sources by parasitoids depends on
several factors such as moth part morphology, flower morphology, and flower color [19][20][21][22].
Apart from the nectar's nutritional content, the accessibility of the parasitoids in the nectar is also
essential. The accessibility of parasitoids in nectar is closely related to flower morphology. Flowers
with exposed nectar will be more accessible to parasitoids. This flower will undoubtedly support the
parasitoids' continuity so that the pest population will be more viable.
Therefore, this study aims to determine the refugia plant longevity of D. semiclausum and changes
in the direction of refugia flower morphology. This study's results can be used to consider suitable
refugia plant species to manipulate the cabbage planting habitat, especially for D. semiclausum adult’s
survival.
2. Methods
2
International e-Conference on Sustainable Agriculture and Farming System IOP Publishing
IOP Conf. Series: Earth and Environmental Science 694 (2021) 012049 doi:10.1088/1755-1315/694/1/012049
Refugia plants are grown or transplanted into a planting medium with the soil's composition: compost
(1: 1). Plant maintenance was carried out by sufficient watering.
3
International e-Conference on Sustainable Agriculture and Farming System IOP Publishing
IOP Conf. Series: Earth and Environmental Science 694 (2021) 012049 doi:10.1088/1755-1315/694/1/012049
1.0 A B
Survival probability of D. semiclausum adults
0.9
0.8
0.7
K+
0.6 K-
0.5 Rid
Str
0.4 Aco
0.3 Brp
0.2
0.1
0.0
0 2 4 6 8 10 12 14 16 18 20 22 0 2 4 6 8 10 12 14 16 18 20 22
Figure 1. Survival probability of D. semiclausum adults. (A) Female, (B) Male. K+: positive
control, K-: negative control, Rid: R. indica, Str: S. trilobata, Aco: A. conyzoides, Brp: B. rapa.
Nectar in refugia flowers generally has a positive effect on D. semiclausum longevity. Refugia
flower nectar can increase D. semiclausum adults' longevity to 1.7 - 3.7 times compared to the
negative control (water treatment). Several flowers affected increasing the imago's longevity, which
was not significantly different from the positive control treatment (10% honey solution). Flower nectar
and other carbohydrate sources can increase life and parasitoid meridians length in laboratory and
field-scale tests [23][24]. The presence of flower nectar is vital as a source of nutrition that determines
parasitoid survival. Parasitoids generally emerge first from their host with limited energy availability,
so they can only last 1-2 days without food [25][26]. Research by Winkler et al. [27] also stated that
the adult of D. semiclausum could only survive less than two days without eating. This causes, after
leaving the host, the parasitoid will start searching for food sources first rather than searching for the
host [28][29]. The parasitoids D. semiclausum is synovigenic parasitoids [30]. This parasitoid must
continuously ripen eggs during their reproductive period so that the presence of nectar as a nutrition
source will benefit from increasing fecundity and reproductive rate of eggs and increasing longevity
[31][32].
The R. indica flower had the best effect on the D. semiclausum adults' longevity, followed by the
treatment of B. rapa and A. conyzoides flowers. Brassicaceae family plants, such as R. indica and B.
rapa, have been reported to have had a fairly good effect on Diadegma adults' longevity. The nectar of
kale flowers as a source of carbohydrates can increase the survival of Diadegma insulare imago (4-28
days) and not different with 15% honey treatment (27-28 days), while water treatment is only 0-1 days
[33]. The results of Johanowicz and Mitchell's [34] study showed that the survival of D. insulare was
supported by Lobularia maritima (L.) Desc (1-53 days) compared to water treatment (1-4
days). Barbarea vulgaris, Brassica kaber, and Dacus carota, common in cabbage planting areas, can
affect D. insulare. Barabarea vulgaris can increase the longevity up to more than 20 days, not
significantly different from the honey solution treatment, while water treatment is only about two days
[24]. Longevity average of D. semiclausum adults feeding on the Fagopyrum esculentum Moench cv.
Katowase flowers are 15 / 14.2 (male / female) times higher (30.3 / 25.6 days), compared to water
treatment (2 / 1.8 days), flower treatment was not significantly different from honey [35].
4
International e-Conference on Sustainable Agriculture and Farming System IOP Publishing
IOP Conf. Series: Earth and Environmental Science 694 (2021) 012049 doi:10.1088/1755-1315/694/1/012049
12
Corolla length
Corolla aperture
10
Flower measurments (mm)
0
R. indica B. rapa A. conyzoides S. trilobata
Refugia flower
5
International e-Conference on Sustainable Agriculture and Farming System IOP Publishing
IOP Conf. Series: Earth and Environmental Science 694 (2021) 012049 doi:10.1088/1755-1315/694/1/012049
flower shape or morphology. Flower petals and sepal's position can influence nectar access. As
reported on Brassica kaber flowers by Idris and Grafius [24], B. rapa and R. indica flowers have
separate petals and sepals, causing the nectar found in the basal part of the flower to be exposed. This
character causes the nectar of B. rapa to remain accessible to D. semiclausum imago even though it
has a long (deep) corolla.
20
18
16
longevity (days)
14
12
10
8 y = 0.6138x + 10.682
R² = 0.1323 (Female)
6
4
y = 0.5528x + 10.338
2 R² = 0.105 (Male)
0
0 1 2 3 4 5 6 7 8
Corolla lenght (mm)
20
18
16
14
Longevity (days)
12
10
8 y = 0.4438x + 11.648
R² = 0.2482 (Female)
6
4 y = 0.4253x + 11.115
Female Male
R² = 0.2231 (Male)
2 Linear (Female) Linear (Male)
0
0 1 2 3 4 5 6 7 8 9 10 11 12
Corolla aperture (mm)
Figure 3. Regression analysis between D. semiclausum longevity and flower morphology. (A)
corolla length, (B) corolla aperture.
The long flower corolla should make it more difficult for the parasitoids to access the nectar
because it does not have mouthparts to reach the nectar. However, due to the exposed flower
characteristic (sepals and petals are separate), parasitoids can still access. Based on the observation,
6
International e-Conference on Sustainable Agriculture and Farming System IOP Publishing
IOP Conf. Series: Earth and Environmental Science 694 (2021) 012049 doi:10.1088/1755-1315/694/1/012049
the parasitoid will have easier access to a flower even though it has a long corolla, but with the width
aperture and the exposed nectar location. Even though the flower has a short corolla, but the nectar is
hidden, the parasitoid cannot access it, so that the longevity will be shorter.
4. Conclusion
All refugia flower tested could increase D. semiclausum longevity than the negative control treatment.
The R. indica flower showed the best effect in increasing D. semiclausum longevity compared to other
treatments (female: 3.69 times, male: 3.65 times). The length and aperture of corolla flowers are
positively correlated with the longevity of parasitoids. The exposed flower nectar will make it easier
for the parasitoid to exploit it. The corolla aperture and the nectar location have more substantial
effects than the corolla length.
Acknowledgments
The authors wish to thank the Ministry of Education and Culture and the Ministry of Research and
Technology through the PMDSU Batch IV scholarship program for providing research grants.
References
[1] Wang XG, Duff J, Keller MA, Zalucki MP, Liu SS, Bailey P 2004 Biocontrol Sci Tech
14(6):571-86 DOI: 10.1080/09583150410001682304
[2] Mauliina F, Muflihayati 2008 Int J Adv Sci Eng Inf Technol 3(5):6-8
[3] Wardani N, Nazar A 2002 J HPT Tropika 2(2):55-60
[4] Hill TA, Foster R 2000 J Econ Entomol 93(3):763-8
[5] Pandey S, Rahman A, Gurr GM 2017 Entomol Exp Appl 166:265-76.
[6] Wratten SD, Lavandero BI, Tylianakis J, Vattala D, Cilci T, Sedcole R 2003 NZPPS 56:239-
45.
[7] Landis DA, Wratten SD, Gurr GM 2000 Annu Rev Entomol 45:175-201
[8] Afrin S, Latif A, Baru NMA, Kabir MMM, Haque SS, Ahmed MME, Tonu NN, Ali MP 2017
Agric Sci 8:112-34.
[9] Lu ZX, Zhu PY, Gurr GM, Zheng XS, Read DMY, Heong KL, Yang YJ, Hu HX 2012 Insect
Sci 21:1-12
[10] Geneau CE, Wackers F, Luka H, Balmer O 2013 Biol Contr 66(1):16-20
[11] Baggen LR, Gurr GM 1998 Biol Contr 11:9-17.
[12] Luna JM, Colley M, Staben M 1999 Infor Bull Organic Farming Res Org 6:7-9.
[13] Zhao JZ, Ayers GS, Grafius EJ, Stehr FW 1992 Great Lakes Entomol 25:253-8.
[14] Taylor RM, Pfannenstiel RS 2008 Environ Entomol 37:996-1002.
[15] Winkler K, Wackers F, Kiss-Bukovinszkine G, van Lenteren J 2006 Basic App Ecol 7:133-40
[16] Pandey S, Rahman A, Gurr GM 2017 Entomol Exp Appl 166:265-276. DOI:
10.1111/eea.12668.
[17] Seni A 2018 ASAG 2(2):8-11
[18] Geneau CE, Wackers FL, Luka H, Daniel C, Balmer O 2012 Basic Appl Ecol 13:85-93
[19] Patt JM, Hamilton GC, Lashmod JH 1997 Entomol Exp Appl 83:21-30
[20] Jervis M 1998 Biol J Linn Soc 63:495-535
[21] Begum M, Gurr GM, Wratten SD, Nicol HI 2004 Biol Contr 30:584-90.
[22] Wacker FL 2004 Biol Contr 29:307-14.
[23] Foster MA, Ruesink WG 1984 Environ Entomol 13: 664-8
[24] Idris AB, Grafius E 1996 Proceedings of the Third International Workshop: The Management
of Diamondback Moth and Other Crucifer Pest. (Kuala Lumpur) pp 90-6
[25] Olson DL, Nechols JR 1995 Environ Entomol 24:454-8
[26] Steppuhn A, Wackers FL 2004 Func Ecol 18:812-9
[27] Winkler K, Wackers FL, Buitriago L, van Lenteran JC 2005 Proc Netherland Entomology Soc
Meet 16:125-30
7
International e-Conference on Sustainable Agriculture and Farming System IOP Publishing
IOP Conf. Series: Earth and Environmental Science 694 (2021) 012049 doi:10.1088/1755-1315/694/1/012049