Professional Documents
Culture Documents
Zannat
Zannat
Dept. of EEE
Report on:Electrical and Electronic Circuit
simulation Laboratory (EEE-3200)
Newly added
5) Simulating self-excited DC Shunt Motor Characteristics using
MATLAB Simulink.
6) Simulating separately excited DC Motor Characteristics using
MATLAB Simulink
7) Modeling of Single-phase induction motor using MATLAB
Simulink.
8) Simulation of Single-Phase Transformer using MATLAB
Simulink.
9) Design and modeling of 200-Watt Solar (PV) Module in
MATLAB Simulink.
Experiment no:01
Experiment name: Simulation of Half Wave Rectifier without filter Using
MATLAB.
Simulation:
Output:
Simulation:
Output:
Discussion: According to the circuit we have plotted all the required elements in
our simulink plot.Then we run the simulation.After clicking on the scope block ,we
have got four different waveform that is given above.
Experiment no:03
Experiment name: Simulation of Full Wave bridge Rectifier Using MATLAB.
Aparatus:MATLAB software with simulink.
Circuit:
Simulation:
Output:
Discussion: According to the circuit we have plotted all the required elements in
our simulink plot.Then we run the simulation.After clicking on the scope block ,we
have got four different waveform that is given above.
Eperiment no:04
Experiment name: Simulation of Center Tapped Full Wave Rectifier Using
MATLAB.
Simulation:
Output:
Discussion: According to the circuit we have plotted all the required elements in
our simulink plot.Then we run the simulation.After clicking on the scope block ,we
have got four different waveform that is given above.
Experiment no:05
Experiment name: Simulating self-excited DC Shunt Motor Characteristics
using MATLAB Simulink.
Fig:Scope Output
Experiment no:06
Experiment name:Simulating separately excited DC Motor Characteristics
using MATLAB Simulink.
Discussion: : According to the circuit we have plotted all the required elements
in our simulink plot.Then we run the simulation.After clicking on the scope block
,we have got four different waveform that is given above.
Experiment no:07
Experiment name: Modeling of Single-phase induction motor using MATLAB
Simulink.
Discussion: : According to the circuit we have plotted all the required elements
in our simulink plot.Then we run the simulation.After clicking on the scope block
,we have got three different waveform that is given above.We can see output for
capacitor start and capacitor start and run both by simply changing the mode.
Experiment no:08
Experiment name: Simulation of Single-Phase Transformer using MATLAB
Simulink.
Simulation:
output:
Discussion: : According to the circuit we have plotted all the required elements
in our simulink plot.Then we run the simulation.After clicking on the scope block
,we have got four different waveform that is given above.This is for the step down
transformer as we can see that secondary voltage is lower than the primary.We can
also see the output of step up transformer simply by changing the value of primary
and secondary winding.
Experiment no:09
Experiment name: Design and modeling of 200-Watt Solar (PV) Module in
MATLAB Simulink.
Fig:Photovoltaic cell
Simulation:
Output:Here the display output is same as the selected model’s data sheet value.
Current at maximum power point Imp (A) at display1=7.584A
Discussion: : According to the circuit we have plotted all the required elements
in our simulink plot.Then we run the simulation.The display outputs are same as
the data sheet.Thus the simulation is done.We can also the waveform through the
scope if we want.