Professional Documents
Culture Documents
PAFM250W Rev3.1
PAFM250W Rev3.1
___________________________________________________________________________
250W - PROFESSIONAL FM POWER AMPLIFIER MODULE
Designed for FM radio transposers and transmitters, this amplifier incorporates ALL-IN-ONE technology and MOSFET
transistors to enhance ruggedness and reliability.
General characteristics:
● 87.5 - 108.0 MHz.
● 48 Volts.
● Input/Output 50 Ω .
● Pout : 250 W NOMINAL, 300 W max.
● Gain : 14 dB typical.
● Output -60dB Low Pass Filter (L.P.F.).
● Fuse protection (10A).
● FWD/SWR output sensors, FWD input sensor and Temperature sensor1.
● Input 2.5dB attenuator.
● Devices: MRF151 or equivalent.
1.
Temperature sensor installed: LM35, LM335, LM50, DS18B20 or similar.
CONNECTIONS:
1. RF Input (0-20W). You connect 50 ohm coaxial cable (RG316 or RG178 type) in this connection.
2. FWD Input Sensor 2-pin connector. 1= VFWD INPUT, 2=GND
3. Temperature sensor 3-pin connector.
If LM35 installed ---------------------------- 1= GND , 2= VOUT , 3= VS
If LM335 installed --------------------------- 1= - , 2= + , 3= ADJ
If DS18B20 installed ------------------------ 1= GND , 2= DQ , 3= VDD
If DS18B20-PAR (DS18B20P) installed --- 1= GND , 2= DQ , 3= NOT CONNECTED
If DS18S20 installed ------------------------ 1= GND , 2= DQ , 3= VDD
If DS18S20-PAR (DS18S20P) installed --- 1= GND , 2= DQ , 3= NOT CONNECTED
4. V-Bias. Control V bias MOSFET 1.
5. Fuse (10A-11A). You use 10A or 11A max. fuse.
6. FWD/SWR Output Sensors 3-pin connector. 1=VFWD OUTPUT, 2=GND, 3=VSWR/RFL/ROE
7. RF Output (0-250W). You connect 50 ohm coaxial cable (RG303, RG400 or RG142 type) in this
connection.
8. +48V input power supply connection Vs. Connect BLACK/GND to GND/Earth and RED/+48V to
you +48V power supply. +48V/9A min. RECOMMENDED.
9. V-Bias. Control V bias MOSFET 2.
MECHANICAL: