01. Design axial force for the specified column, and the shear core, at Levels N-1, N-2, N-5 and N-10 due to gravity loads. (Out of 10) 02. Design moments (envelope of BM and SF) for the specified floors beam and the connected columns, due to gravity loads. (Out of 20) 03. Shear forces, bending moments, displacements, and story drift of the core and frame using the approximated analysis, under the given uniform wind load at each floor level (graphs of each parameter should be created). (Out of 20) 04. Concentrated interaction force QH (from approximated analysis) at the top of the specified frame and the beading moment and shear force in its roof beam and connected columns due to QH using the cantilever or portal method. (Out of 10) 05. Variation of the wind press acting on the building, for wind acting from Y-direction, according to Wind Code. (Out of 10) 06. Along –wind acceleration according to wind Code. (Out of 10) 07. Total base shear due to an earthquake of magnitude 0.1 g acting in the Y-direction (Using equivalent static force method). (Out of 10) 08. Variation of this base shear over height. (Out of 10) 09. Developing FE model for your building (Out of 15) 10. Frequencies and mode shapes for the first four modes. (Out of 10) i. Only for self-weight ii. Self-weight + Total dead load + 30% of live load 11. Design axial forces referred to in 01 above at the Level 1 of the building. [Comparison values must be included] (Out of 10) 12. The values specified in 03 above (displacements, story drift, shear forces and bending moments). [Comparison graphs must be included] (Out of 15) 13. Variation of deflection of the specified column and the core, under serviceability condition, with wind pressure found in 05 above, and the drift index. (Out of 10) 14. Conducting modal time history analysis for given ground motion data; obtain the response (max. displacement, velocity and acceleration at each floor level) of your building model. (Out of 20) 15 Conducting Modal RS analysis for given data (07); obtain the response (displacement and base shear at each floor level) of your building model. [Comparison graphs must be included] (Out of 20)