Professional Documents
Culture Documents
RFIC COURSE HANDOUT New
RFIC COURSE HANDOUT New
Course Credits :3
Course Objective :
An ability to define basic architecture RF systems, different RLC Circuits and transmission
media and reflections and maximum powers transfer theorem
An ability to define the MOS device review, Distributed Systems
An ability to understand the LNA Design and the different design examples & Multiplier
based mixers. Mixer Design, Subsampling mixers
An ability to derive the Class A, AB, B, C amplifiers, Class D, E, F amplifiers, RF Power am-
plifier design examples and to perform simple projects with a few PLL’s
An ability to understand Frequency synthesis and oscillators and GSM radio architectures,
CDMA, UMTS radio architectures.
Course Rational :
CO No CO BTL
Students are able to Understand Transmission Lines to, from, and inside understanding
1
RFICs
Students are able to design Multiplier based mixers. Mixer Design, Subsam- Applying
2
pling mixer
Students are able to Quantify the noise contributions of various structures Applying
3
on an RFIC
Students are able to Demonstrate Class A, AB, B, C amplifiers, Class D, E, F Applying
4
amplifiers
Students are able to Recognize the project management and demonstrate a Applying
5
GSM, CDMA, UMTS radio architectures
Page 1 | 5
Correlation with program outcome
Course PO1 PO2 PO3 PO4 PO5 PO6 PO7 PO8 PO9 PO1 PO1 PO1
outcom 0 1 2
e
CO1 1 1 - - - - - - - - - -
CO2 3 2 1 1 - - - - - - 1 -
CO3 3 1 1 1 - - - - - - - -
CO4 3 1 1 1 - - - - - - 1 -
CO5 3 2 1 1 - 1 - - - - 2 -
1: Slight (Low) 2: Moderate (Medium) 3: Substantial (High) If there is no correlation, put “-”
SYLLABUS:
UNIT – I Introduction RF systems – basic architectures, Transmission media and reflections,
Maximum power transfer, Passive RLC Networks, Parallel RLC tank, Q, Series RLC networks,
matching, Pi match, T match, Passive IC Components Interconnects and skin effect, Resistors, ca-
pacitors Inductors
UNIT – II Review of MOS Device Physics - MOS device review, Distributed Systems, Transmission
lines, reflection coefficient, the wave equation, examples, Lossy transmission lines, Smith charts –
plotting Gamma, High Frequency Amplifier
Design, Bandwidth estimation using open-circuit time constants, Bandwidth estimation, using
short-circuit time constants, Rise time, delay and bandwidth, Zeros to enhance bandwidth, Shunt-
series amplifiers, tuned amplifiers,
Cascaded amplifiers
UNIT – III Noise - Thermal noise, flicker noise review, Noise figure, LNA Design, Intrinsic MOS
noise parameters, Power match versus, noise match, large signal performance, design examples &
Multiplier based mixers. Mixer Design,
Subsampling mixers.
UNIT – IV RF Power Amplifiers, Class A, AB, B, C amplifiers, Class D, E, F amplifiers, RF Power
amplifier design examples, Voltage controlled oscillators, Resonators, Negative resistance oscilla-
tors, Phase locked loops, Linearized PLL models,
Phase detectors, charge pumps, Loop filters, and PLL design examples
UNIT – V Frequency synthesis and oscillators, Frequency division, Integer-N synthesis, Fractional
frequency, synthesis, Phase noise, General considerations, and Circuit examples, Radio architec-
tures, GSM radio architectures, CDMA,
UMTS radio architectures
Text books:
1. The design of CMOS Radio frequency integrated circuits by Thomas H. Lee Cambridge
university press, 2004.
2. RF Micro Electronics by BehzadRazavi, Prentice Hall, 1997.
Reference Books:
Page 2| 5
1. https://nptel.ac.in/courses/117/102/117102012/
Sess Tentative
CO Teaching- Evaluation
. Date to
Topic (s) Learning Component
BTL Complete
No Methods s
Topic
UNIT I Introduction RF systems
1 understan Introduction RF systems – Chalk and
Quiz 14-03-2022
d basic architectures talk
2 understan Transmission media and re- Chalk and
Quiz 15-03-2022
d flections talk
3 understan Chalk and
Maximum power transfer Assignment 16-03-2022
d talk
4 Apply Chalk and
Passive RLC Networks Test 17-03-2022
talk
5 Apply Chalk and
Parallel RLC tank Quiz 17-03-2022
talk
6 Analyze Chalk and
Quality factor Q, Test 18-03-2022
talk
7 Analyze Chalk and
Series RLC networks Quiz 18-03-2022
talk
8 understan Chalk and
matching, Pi match, Assignment 19-03-2022
d talk
9 understan
T match PPT Assignment 22-03-2022
d
10 understan Passive IC Components Chalk and
Quiz 23-03-2022
d Interconnects and skin effect talk
11 understan Resistors, capacitors
PPT Quiz 24-03-2022
d Inductors
UNIT II Review of MOS Device Physics
12 Analyze Review of MOS Device Physics Chalk and
Quiz 26-03-2022
- MOS device review talk
Page 4| 5
d detectors talk
38 Analyze Chalk and
charge pumps, Loop filters Quiz 17-06-2022
talk
39 Analyze Chalk and
PLL design examples Quiz 21-06-2022
talk
UNIT - V
40 understan Frequency synthesis and
PPT Assignment 24-06-2022
d oscillators
41 understan Frequency division, integer-N Chalk and
Test 25-06-2022
d synthesis talk
42 Apply Fractional frequency, synthe- Chalk and
Assignment 28-06-2022
sis talk
43 Apply Phase noise, General consid- Chalk and
Quiz 29-06-2022
erations, and Circuit examples talk
44 Analyze Radio architectures, GSM ra- Chalk and
Assignment 30-06-2022
dio architectures talk
45 Analyze CDMA,UMTS radio architec- Chalk and
Mid exam-II 02-07-2022
tures talk
Chamber
Chamber Chamber Signature of
Consultatio
SL.No. Name of Faculty Consultation Consultatio Course
n Timings
Day(s) n Room faculty
for each day
Staff Room
MONDAY-
1. P.Hemalatha 12.50-1.40 ECE
SATURDAY
Department