Professional Documents
Culture Documents
Schematic PDF - (No Variations)
Schematic PDF - (No Variations)
Schematic PDF - (No Variations)
3
These are the voltage and current Ilim_signal
~ +12 Vcc Q1
~
set point controls respectively 2
- + - + 1N4007-T BC327-25ZL1G
1
~
1
C1 C2 +9 R2 Q2
Vlim_signal 2
2
1000 uF 4700 uF BC337-40ZL1G
10K
1 Q3
8
U1A
3
TIP120G
VAC_COM VAC_COM P1 +5 Vmeas 2 LM358NG C3
+
100n C4
1 1 Vlim_signal R3 10uF
GND GND GND GND 2 Vset 3 10K
3
3
+9
4
Vset_pot GND
GND GND R4
AUX POWER SUPPLIES 100mΩ
GND +9 C5 U2 Vout
+12 U3 L7805CV +5 +12 U4 UA78L09ACLP +9 10n 3 4
1 3 3 1 V+ Vin+
B IN OUT IN OUT 2 B
GND
8
GND COM U1B Imeas 1 5 R5
C6 C7 P2 OUT Vin-
C8 C9 +5 Imeas 6 LM358NG 100k
10u 1u 1 7 Ilim_signal TI INA196AIDBVT
2
10u 1u
2 Iset 5 GND Vmeas
3
1
2
INA196 gain =20V/V
Vout = 0-30V
4
Iset_pot Reference Voltage = 5V R6
1
2
GND GND Vref = 5V 22k
-> V_Rsense(full scalse) = 5/gain
9V supply for opamps, INA196 current monitor and arduino. TO-92 -> 6:1 voltage divider
J1 = 250mV
100mA regulator is fine
GND Ilim Jumper Maximum Current = 2.5A
5V is output to front panel, and powers display, tap select relay and serves
Jumper to enable/disable -> Rsense = V/I
as reference voltage. Needs TO-220 1A regulator
current limiting = 100mOhm GND
ARD_D3 5 2k2
LCD_EN 6
D ARD_D4 6 Title D
LCD_D4 7 Low voltage range:
ARD_D5 7
LCD_D5 8 Vmeas < Vset
Lab Supply
ARD_D6 8 GND
GND LCD_D6 9 -> opamp output = high
GND GND Size Number Revision
LCD_D7 10 R10 -> turn on transistor
CONN_AUX GND
-> close relay A4
1.1
CONN_LCD 33k
Date: 8/07/2021 Sheet of
File: c:\net\..\lab_supply.SchDoc Drawn By: Matt Godfrey
1 2 3 4