Professional Documents
Culture Documents
Hempafloor Fill 200
Hempafloor Fill 200
Recommended use: Designed to fill imperfection irregularities and fairing the surface of interior and exterior
concrete floor prior to applying topcoats of the Hempafloor range.
Availability: Available in 5Kg (Packing may vary from country to country depending on local requirements).
Physical constants*:
Colours/shade Nos.: Grey/11630
Finish: Matt
Volume solids, %: 100
Theoretical spreading rate: 2 kg/m² 1 mm DFT**
Flash point: >235°C
Specific gravity: 1.94 kg/litre
Dry to touch: 7 hours at 10°C 3½ hours at 20°C 1½ hours at 40°C
Initial hardness: 24 hours at 20°C
Fully cured: 7 days before the floor can be exposed to heavy duty traffic
VOC content: 10g/litre
*The physical constants stated are nominal data according to the Hempel Group's approved formulas.
They are subject to normal manufacturing tolerances and where stated, being standard deviation
according to ISO 3534-1.
**The theoretical spreading rate has been calculated for the stated volume solids and dry film thickness. A
practical spreading rate will depend on the actual dry film thickness, the nature of the substrate and
relevant consumption factor. The physical constants are subject to normal manufacturing tolerances.
Further references can be found in the "Explanatory Notes".
Application details:
Mixing ratio: 78:22 by weight
Application method: Putty knife
Thinner (max.vol.): Do not dilute
Pot life: 60 minutes (20°C) Reduced at higher temperature
Cleaning of tools: Hempel Tool Cleaner 99610
Indicated film thickness, dry: From 1 to 5mm
Indicated film thickness, wet: From 1 to 5mm
Overcoat interval, min: 48 hours at 10°C 24 hours at 20°C 12 hours at 40°C
Overcoat interval, max: 6 days at 10°C 72 hours at 20°C 36 hours at 40°C
Safety: Handle with care before and during usage. Read all labels on packaging and paint containers
before usage, consult Hempel for any inquiries. Material Safety Data Sheets follows all local
and national safety regulation. Avoid inhalation, avoid contact with eyes and skin. Do not
swallow. Take precautions against possible risks of fire or explosion. Apply only in well
ventilated areas. Remember to protect the environment.
Substrates: Concrete
Application conditions: Application can only proceed at temperatures above 10°C and relative humidity below 75%.
Other sealer/filler types may be specified. Drying data are given on the assumption that proper
ventilation is provided. Hempafloor Fill 200 should not be applied to concrete with more than
4% moisture. Areas repaired with fillers are recommended for touch ups using primer/sealer
prior to applying topcoats.
Surface preparation: The surface should be stable, firm, dry and free from dust, sand, loose old paint, laitance, dirt,
grease and oil. Proper surface preparation is a must, mechanical surface preparation is highly
recommended (see Hempafloor Surface preparation brochure or consult our Technical
representatives).
Mixing: Hempafloor Fill 200 is a two component material (base and curing agent) which must be mixed
together prior to use. Stir the base (Part A), continue stirring whilst adding all the contents of
the curing agent (Part B) and mix until homogeneous. No part mixing.
Application: • All cracks and holes should be marked, cleaned, dried and free from any
contaminations.
• Apply the mixed product to the surface with a good quality putty knife or steel trowel.
Storage & handling: Product must be stored as per local regulation. Keep in dry and ventilated location, far from
heat and direct sunlight.