Professional Documents
Culture Documents
Manual Gratis Chery Tig Go
Manual Gratis Chery Tig Go
Manual Gratis Chery Tig Go
http://www.autodaewoospark.com/manuales-chery-tiggo-servicio-usuario.php
Atentamente,
Jorge E. Penagos P.
http://www.autodaewoospark.com
1 - Air Outlet 5 - Radio 9 - Hazard Warning Flasher Switch 13 - Front Ashtray 17 - Hood Release Lever
18 - Headlight Leveling
2 - Steering Wheel 6 - Passenger Side Airbag 10 - Cigarette Lighter 14 - Cruise Control Switch
Switch
15 - Remote Audio System
3 - Instrument Cluster 7 - Glove B ox 11 - RH Heated Seat S witch 19 - Rear Fog Light Switch
Controls
4 - Driver Side Airbag 8 - Climate Control Panel 12 - LH Heated Seat Switch 16 - Dimmer Control Switch 20 - Front Fog Light Switch
Instrument Cluster
98 – IN CASE OF AN EMERGENCY
A blown fuse can be identified by the Fuse Color Amperage CAUTION! (Continued)
melted fuse wire. Pink 40 A
Yellow 60 A • Do not attempt to tow this vehicle
from the front with sling type tow-
Towing A Disabled Vehicle ing equipment. Damage to the front
fascia will occur.
NOTE: Your vehicle is equipped with
tow hooks at both the front and rear.
Removing and Installing
CAUTION! Vehicle Battery
The following steps must be taken
Observe the following guidelines when
when removing and installing the bat-
towing the vehicle:
tery:
• Tow the vehicle slowly and smoothly • Turn the ignition switch and all elec-
to avoid damage. trical devices off.
• If the vehicle needs to be steered • Remove the negative (-) battery
while being towed, the ignition cable.
switch must be in the ON position,
not in the LOCK or ACC position.
Fuse Color Amperage
• Power brake and power steering as-
Auburn 5A
Brown 7.5 A sist is not unavailable when the en-
Red 10 A gine is off, the required operational
Blue 15 A force is increased significantly.
Yellow 20 A
(Continued)
Green 30 A
Chapter 1 Overview
Engine used in Chery Tiggo car is MITSUBISHI 4G64 (2.4L) and 4G63 (2.0L)
model engine, which adapt single-overhead-camshaft, 4-cylinder 16-valve and multi-point
sequential injection.
I. Technical Data
Engine No.
2
Features
Features
12
8.8N.m
8.8N.m
Disassembling
illustration
23
1. Schematic Diagram
Schematic Diagram
7. Release Bearing Saddle 15. Synchronizer of 5 -Gear and Reserve Gear
th
92
118
1) Removal
b. Remove brake caliper, and refer to the section of "Disc brake" to replace the bracket of brake
caliper.
c. Refer to the replacement of brake disc to remove rear brake disc.
20
Battery
Brake Indication Lamp
Diagnostic Interface
Combination Instrument
40
Torque:
-28-