Professional Documents
Culture Documents
Sample Questions
Sample Questions
Q2. If carbon content is 0.02 in one item and 0.05 in other item which is more easily weldable.
Q3. In a nickel alloy material welding, a filler metal must have higher nickel content than base metal (T/F)
Q4. Which one is the compulsory mechanical test for a welder qualification:
a) Side bend test, b) Root bend test, c) face bend test d) All of above
Q5. Is welding code D1.1 is always requires a qualification of WPS or are there some pre qualified WPS?
Q6. If a pre qualified procedure is being used than Welder qualification is also required? (T/F)
Q8. What should be tested prior to base metal welding of cladded plate
a) ensure cladded metal is removed by testing b) ensure WPS is approved c) all of above
Q11. If a welder is qualified for 6G position, is he qualified for all positions of groove or fillet?
Q21. Circular weld should be welded before longitudinal weld of tank shell (T/F)
Q22. Surface minor cark tightly filled with slag in SS plate can be detected by
a) UT, b) RT, c) MT, d) PT, e) VT
Q27. If an essential veriable of WPS is changed than qualification of WPS is required (T/F).
Q28. Inspector should be well known and honest and technically sound (T/F),
Q29. If a weld defect is observed than whome should be contacted.
a) Welder, b) Another better welder, c) Project Engineer, d) QC supervisor
Q35. What defects will come if Root face gap is very less than requirement.
a) burn through, b) lack of fusion c) higher penetration d) None of above
Q36. For dimensional inspection which document should be referred for a specific equipment
a) equipment drawing, b) Code, c) standard
Q38. Porosity comes due to gas entrapment and solid inclusion is due to solid entrapment (T/F)
Q39. Which is most appropriate welding process for root pass? (GTAW, SMAW, GMAW SAW)
Q41. If a conflict comes during fabrication of any equipment than manufacturer/vendor will be followed
because client has accepted initial technical querry and approved. (T/F)
Q47. Electrode selection is determined from the base metal chemistries and the percent of weld metal dilution in
most cases the Arosta or Limorosta 309S electrode can be used. When the chemistries are not known, our
Limorosta 312 electrode , which produce a high ferrite number is commonly used.