Professional Documents
Culture Documents
Mount Covers Clea Ceiling: © 2004 Koninklijke Philips Electronics N.V. All Rights Reserved
Mount Covers Clea Ceiling: © 2004 Koninklijke Philips Electronics N.V. All Rights Reserved
LIST OF PAGES & DRAWINGS MODULE CODE NUMBER 4522 981 01913
1 ... 5 (04.0)
Contents
1. INTRODUCTION .....................................................................................................................................2
1.1. Required tools..........................................................................................................................................2
2. MOUNT COVERS....................................................................................................................................3
1. INTRODUCTION
This module describes the procedure to mount the covers of the Clea Ceiling Stand.
2. MOUNT COVERS
NOTE
Mounting procedure and installation materials are exactly the same for systems with I.I. and FD.
• Mount the three covers on top of the L-arm (fitted with Velcro).
• Mount the L-arm side cover (3 countersunk screws, 3 countersunk washers and 3 anti-loss washers)
• Mount the rear cover on the L-arm (6 non-removable screws).
• Insert 6x decorative plastic covers (sealing caps) in the L-arm rear cover.
• Insert 4x sealing cap M16 in the holes of the C-arc junction that have been used for the fixation of the
installation frame.
• Mount the metal cover on both sides of the longitudinal carriage (2 screws and 2 washers).
• Mount the rotation cover to the L-arm rotation point (click-construction).
• Insert 4x decorative plastic covers (sealing caps) to bottom side of longitudinal carriage.
3. POSITION STICKERS
HEP LEP
Rubber Rubber
stops stops
+100mm