Professional Documents
Culture Documents
CFD Assignment-5
CFD Assignment-5
CFD Assignment-5
Roll N0 : 22CH60R75
Assignment -5
STEP:-1 Open the Workbench software and create the FLUID FLUENT as shown in the
figure below.
STEP:-2
Create Geometry of a plane with dimensions height-60cm width-40 cm.
Make a circle with diameter 5 cm center of circle is 20 cm away from bottom of
slab 2-D
Its look like the following pic
STEP:-3
After creating the geometry, create a MESH of element size 5mm.
Name the all walls as insulated wall .
After creating mesh and giving names to the edges the mesh looks like below. y.
STEP:-4
Now Open the SETUP part.
Select the 2D planar option.
Set laminar normally though there is no fluid flow but keep the laminar flow
option normally and select transient option .
Now switch on the energy model. In materials solid.
Go to the boundary condition the give the heated cylinder as 650 oC. and all walls
are at temperature of 28 oC.
Select the solution method scheme as SIMPLE.
In the residual option select the convergence to 10^(-25) for energy part.
Select the initialization method as STANDARD INTIALIZATION and compute
from heated cylinder and the select initialization.
After initialization part select the patch option as shown in the figure below.
select the temperature option give temperature as 28 oC and select the surface
body option.
STEP:-5
Go to the calculation option then give the number of time steps as 600 and maximum
time step iterations 20 with time step size as 0.1 sec .
Now calculate .
STEP:-6
Go to the result part then develop the temperature contour it looks like below
figure.
STEP:-7
Go to the result part then develop the velocity contour it looks like below figure.