Professional Documents
Culture Documents
ACFrOgCmm5iARiItTFVJrJRhbskfj25vxB8RxBZ0P4NXl036pGFWeiYjaMegh4 - M8aO7cHgmogDFD7TQOr 0mKJWa bHbjWeXiEeoeCYyibB MrOk1FsHreXZmPV23b wJiti06tQe23g9Vn665
ACFrOgCmm5iARiItTFVJrJRhbskfj25vxB8RxBZ0P4NXl036pGFWeiYjaMegh4 - M8aO7cHgmogDFD7TQOr 0mKJWa bHbjWeXiEeoeCYyibB MrOk1FsHreXZmPV23b wJiti06tQe23g9Vn665
(dept. which you belong to and who you will present it to)
PRESENTED TO THE FACULTY OF ENGINEERING
YOUR SUC
BY
CHRONOLOGICAL ORDER BASED ON SURNAME FIRST, FIRST NAME
EG. SARMIENTO, PRIL
(DATE OF SUBMISSION)
MAY, 2023
INTRODUCTION
(you should first begin your paragraph of the problems covering your proposed
title’s issue/problems)
Despite its natural positioning majority of Filipino’s do not have access to potable water.
not have access to potable water. Water service providers (WSPs) themselves have the
burden of providing water and about half are very small and unregulated or is unable to
adopt to new standards. The proposed title could provide potable water for the targeted
community who are mostly deprived of the most essential necessity, water.
There are certain problems in communities, such as, open defecation. Many low-
untreated and ends up contaminating ground water – the water then gets pumped from
Waterborne diseases pose serious health problems that are common for
communities such as Indigenous People (IP) where often they drink unfiltered,
The proposed water filtration prototype will collect rain water and store it in a
drum. Upon collection it will have already filtered large debris that have been brought by
wind and pumps it towards the water filtration device that will then store it in another
container that can then be used to drink. The proposed prototype will be solar powered
hence there won’t be a need for utility electricity, the harnessed power will be stored in a
battery that will run the filtration system, hence, even during night it will still function but
(this part should cover how the IPs get their source of water, what are the
challenges they face when collecting water, what are the common water related
problems they face, add documentation of when you go there such as pictures)
(this section should identify the key questions in which you are setting your goal
towards achieving)
Water as it may seem trivial, is somewhat becoming scarce and the need to pay
for potable water has put burdens in many Filipinos especially our primary beneficiary
the IPs of Zambales. The proponents came up with the following questions:
1. Can the prototype function fully with just solar power and without the need for
utility electricity?
2. Will the prototype address the need of potable water for the IPs?
4. Will the filtered water pass the 3 types of water quality test?
a. Physical test:
i. Color – which may be caused by presence of minerals, water is
naturally clear.
microscopic organism.
b. Chemical test:
c. Bacteriological test:
GENERAL OBJECTIVE
The general objective of this thesis is to design and develop using our skills and
knowledge into creating a sustainable, cost efficient, and potable water for our target
RESEARCH METHODOLOGY
Title,
Source(where it was published if taken from website use: “retrieved from: url”)
Eg.
Shawn Cleary, Sustainable Drinking Water Treatment For Small Communities Using
https://www.collectionscanada.gc.ca/obj/s4/f2/dsk3/OWTU/TC-OWTU-502.pdf, 2005.