Professional Documents
Culture Documents
Scaledeposit Inhibitor
Scaledeposit Inhibitor
PRODUCT
EC6449A
EMERGENCY TELEPHONE NUMBER(S) : See section 16, for Emergency Telephone Numbers.
For Product Safety information please contact Jacqueline Bland, e-mail EUProductSafety@nalco.com
2. HAZARDS IDENTIFICATION
HAZARD CLASSIFICATION :
This product is not classified as dangerous in accordance with Directives 67/548/EEC or 1999/45/EC. Any
disclosed substance(s) are present below hazardous concentration levels for the product classification.
NALCO EUROPE B.V. Postbus 627 • 2300 AP Leiden • The Netherlands • +31 71 5241 100
For additional copies of an MSDS visit www.nalco.com and request access
1 / 10
SAFETY DATA SHEET
PRODUCT
EC6449A
INHALATION :
Not a likely route of exposure. No adverse effects expected.
SKIN CONTACT :
No adverse effects expected.
EYE CONTACT :
No adverse effects expected.
INGESTION :
Not a likely route of exposure. No adverse effects expected.
3. COMPOSITION/INFORMATION ON INGREDIENTS
This product is not classified as dangerous in accordance with Directives 67/548/EEC or 1999/45/EC. Any
disclosed substance(s) are present below hazardous concentration levels for the product classification.
INHALATION :
Remove to fresh air, treat symptomatically. If symptoms develop, seek medical advice.
SKIN CONTACT :
Flush affected area with water. If symptoms develop, seek medical advice.
EYE CONTACT :
Flush affected area with water. If symptoms develop, seek medical advice.
INGESTION :
Do not induce vomiting without medical advice. If conscious, washout mouth and give water to drink. If reflexive
vomiting occurs, rinse mouth and repeat administration of water.
NOTE TO PHYSICIAN :
Based on the individual reactions of the patient, the physician's judgement should be used to control symptoms
and clinical condition.
EXTINGUISHING MEDIA :
This product would not be expected to burn unless all the water is boiled away. The remaining organics may be
ignitable. Use extinguishing media appropriate for surrounding fire.
NALCO EUROPE B.V. Postbus 627 • 2300 AP Leiden • The Netherlands • +31 71 5241 100
For additional copies of an MSDS visit www.nalco.com and request access
2 / 10
SAFETY DATA SHEET
PRODUCT
EC6449A
PERSONAL PRECAUTIONS :
Restrict access to area as appropriate until clean-up operations are complete. Use personal protective equipment
recommended in Section 8 (Exposure Controls/Personal Protection). Stop or reduce any leaks if it is safe to do so.
Ventilate spill area if possible.
ENVIRONMENTAL PRECAUTIONS :
Do not contaminate surface water.
HANDLING :
Do not get in eyes, on skin, on clothing. Do not take internally. Use with adequate ventilation. Do not breathe
vapors/gases/dust. Keep the containers closed when not in use. Have emergency equipment (for fires, spills,
leaks, etc.) readily available. Ensure all containers are labeled.
STORAGE CONDITIONS :
Store in suitable labeled containers. Store the containers tightly closed.
SPECIFIC USE(S) :
SCALE/DEPOSIT INHIBITOR
For specific dosages and customized applications please contact your representative.
NALCO EUROPE B.V. Postbus 627 • 2300 AP Leiden • The Netherlands • +31 71 5241 100
For additional copies of an MSDS visit www.nalco.com and request access
3 / 10
SAFETY DATA SHEET
PRODUCT
EC6449A
* A skin notation refers to the potential significant contribution to overall exposure by the cutaneous route, including mucous membranes and
the eyes.
MONITORING MEASURES :
A small volume of air is drawn through an absorbant or barrier to trap the substance(s) which can then be desorbed
or removed and analyzed as referenced below:
Substance(s) Method Analysis Absorbant
Glutaraldehyde UK MDHS: 93 High pressure liquid Glass fibre filter
chromatography treated with
Dinitrophenyl
hydrazine
NALCO EUROPE B.V. Postbus 627 • 2300 AP Leiden • The Netherlands • +31 71 5241 100
For additional copies of an MSDS visit www.nalco.com and request access
4 / 10
SAFETY DATA SHEET
PRODUCT
EC6449A
ENGINEERING MEASURES :
General ventilation is recommended. The use of local exhaust ventilation is recommended to control emissions
near the source. Laboratory samples should be handled in a fumehood. Provide mechanical ventilation of
confined spaces.
PERSONAL PROTECTION
GENERAL ADVICE :
The use and choice of personal protection equipment is related to the hazard of the product, the workplace and the
way the product is handled. In general, we recommend as a minimum precaution that safety glasses with
side-shields and workclothes protecting arms, legs and body be used. In addition any person visiting an area
where this product is handled should at least wear safety glasses with side-shields. The applicable European
standard can be found in EN 166.
RESPIRATORY PROTECTION :
Where concentrations in air may exceed the limits given in this section, the use of a half face filter mask or air
supplied breathing apparatus is recommended. A suitable filter material depends on the amount and type of
chemicals being handled. Consider the use of filter type: A-P The applicable European standard can be found in
EN 140, EN 137, EN 143 and EN 14387. In event of emergency or planned entry into unknown concentrations a
positive pressure, full-facepiece SCBA should be used. If respiratory protection is required, institute a complete
respiratory protection program including selection, fit testing, training, maintenance and inspection.
HAND PROTECTION :
When handling this product, the use of chemical gloves is recommended. The choice of work glove depends on
work conditions and what chemicals are handled, but we have positive experience under light handling conditions
using gloves made from PVC Gloves should be replaced immediately if signs of degradation are observed.
Breakthrough time not determined as preparation, consult PPE manufacturers. The applicable European standard
can be found in EN 374.
SKIN PROTECTION :
See general advice.
EYE PROTECTION :
When handling this product, the use of safety glasses with side shields is recommended. The applicable European
standard can be found in EN 166.
HYGIENE RECOMMENDATIONS :
Use good work and personal hygiene practices to avoid exposure. Consider the provision in the work area of a
safety shower and eyewash. Always wash thoroughly after handling chemicals. When handling this product never
eat, drink or smoke.
ODOR None
NALCO EUROPE B.V. Postbus 627 • 2300 AP Leiden • The Netherlands • +31 71 5241 100
For additional copies of an MSDS visit www.nalco.com and request access
5 / 10
SAFETY DATA SHEET
PRODUCT
EC6449A
Note: These physical properties are typical values for this product and are subject to change.
STABILITY :
Stable under normal conditions.
HAZARDOUS POLYMERIZATION :
Hazardous polymerization will not occur.
CONDITIONS TO AVOID :
Heat and sources of ignition including static discharges.
MATERIALS TO AVOID :
Contact with strong oxidizers (e.g. chlorine, peroxides, chromates, nitric acid, perchlorate, concentrated oxygen,
permanganate) may generate heat, fires, explosions and/or toxic vapors.
SENSITIZATION :
The following substance present at very low concentrations, may precipitate an allergic reaction in sensitive
individuals: Glutaraldehyde
CARCINOGENICITY :
None of the substances in this product are listed as carcinogens by the International Agency for Research on
Cancer (IARC), the National Toxicology Program (NTP) or the American Conference of Governmental Industrial
Hygienists (ACGIH).
For additional information on the hazard of the preparation, please consult section 2 and 12.
ECOTOXICOLOGICAL EFFECTS :
MOBILITY :
The environmental fate was estimated using a level III fugacity model embedded in the EPI (estimation program
interface) Suite TM, provided by the US EPA. The model assumes a steady state condition between the total input
and output. The level III model does not require equilibrium between the defined media. The information provided
is intended to give the user a general estimate of the environmental fate of this product under the defined
conditions of the models.
NALCO EUROPE B.V. Postbus 627 • 2300 AP Leiden • The Netherlands • +31 71 5241 100
For additional copies of an MSDS visit www.nalco.com and request access
6 / 10
SAFETY DATA SHEET
PRODUCT
EC6449A
If released into the environment this material is expected to distribute to the air, water and soil/sediment in the
approximate respective percentages;
BIOACCUMULATION POTENTIAL
This preparation or material is not expected to bioaccumulate.
If this preparation becomes a waste, the final user must define and assign the appropriate European Waste
Catalogue code. Use only authorized contractors. Ensure compliance with EC, national and local regulations.
Dispose of wastes in an approved incinerator or waste treatment/disposal site, in accordance with all applicable
regulations. Do not dispose of wastes in local sewer or with normal garbage. This product will generate an ash if
burned. It can be burned directly in appropriate equipment. Any chemical waste is a potential environmental
pollutant and is NOT suitable for disposal via ground, municipal sewers, drains, natural streams or rivers.
Empty drums should be taken for recycling, recovery, or disposal through a suitably qualified or licensed
contractor.
The information in this section is for reference only and should not take the place of a shipping paper (bill of lading)
specific to an order. Please note that the proper Shipping Name / Hazard Class may vary by packaging,
properties, and mode of transportation. Typical Proper Shipping Names for this product are as follows.
LAND TRANSPORT
Proper Shipping Name : PRODUCT IS NOT REGULATED DURING
TRANSPORTATION
NALCO EUROPE B.V. Postbus 627 • 2300 AP Leiden • The Netherlands • +31 71 5241 100
For additional copies of an MSDS visit www.nalco.com and request access
7 / 10
SAFETY DATA SHEET
PRODUCT
EC6449A
TRANSPORTATION
This preparation is not regulated, however, we recommend the following safety precautions:
The following substance present at very low concentrations, may precipitate an allergic reaction in sensitive
individuals: Glutaraldehyde
SAFETY PHRASES
S24/25 - Avoid contact with skin and eyes.
S37/39 - Wear suitable gloves and eye/face protection.
The substances in this preparation have been reviewed for compliance with the EINECS or ELINCS inventories.
Nalco is committed to and fully supports the Registration, Evaluation, Authorization and restriction of CHemicals
(REACH) regulation. It is our intention to pre-register all chemical substances that we manufacture or import into
European Union and to work with our suppliers to ensure a smooth transition to this new regulatory environment.
Should you require any further information on Nalco's REACH programme please contact us at reach@nalco.com
or visit our website.
UNITED STATES :
The substances in this preparation are included on or exempted from the TSCA 8(b) Inventory (40 CFR 710)
NALCO EUROPE B.V. Postbus 627 • 2300 AP Leiden • The Netherlands • +31 71 5241 100
For additional copies of an MSDS visit www.nalco.com and request access
8 / 10
SAFETY DATA SHEET
PRODUCT
EC6449A
CANADA :
The substances in this preparation are listed on the Domestic Substances List (DSL), are exempt, or have been
reported in accordance with the New Substances Notification Regulations.
JAPAN
All substances in this product comply with the Law Regulating the Manufacture and Importation Of Chemical
Substances and are listed on the Existing and New Chemical Substances list (ENCS).
16. OTHER INFORMATION
This product material safety data sheet provides health and safety information. The product is to be used in
applications consistent with our product literature. Individuals handling this product should be informed of the
recommended safety precautions and should have access to this information. For any other uses, exposures
should be evaluated so that appropriate handling practices and training programs can be established to insure
safe workplace operations. Please consult your local sales representative for any further information.
Trans-European +32-(0)3-575-5555
Belgium / Luxembourg +32-(0)3-575-0330
Bulgaria +32-(0)3-575-5555
Croatia +385 (0)91-1-25-75-23
Czech Republic +420-602-669421
Denmark +47-22-33-69-99
Finland +358-(0)9-471 977
France / French Switzerland +33-(0)6-11-07-32-81
Germany / Austria / German Switzerland +49-(0)6232-130128
Hungary +36-30-9-506-447
Italy / Italian Switzerland +39-333-210-7947
Latvia +32-(0)3-575-5555 & Local emergency telephone number 112
The Netherlands +32-(0)3-575-0330
Norway +47-22-33-69-99
Poland +48-(0)601-66-2626 (SGS) / +48 (0) 14 637 40 81 (SPOT)
Portugal +351-91-911-1399
Romania +40-744 -34-14-53
Russia / Belarus +7-812-449-0474
Saudi Arabia +966-(3)847-1515
Serbia +32-(0)3-575-5555
Slovak Republic +421-(0)905-585-938
Slovenia +386-41-634-916
Spain +34-977-551577
Sweden +47-22-33-69-99
UAE +44-(0)7071-223-738
UK and Republic of Ireland +44-(0)7071-223-738
Nalfleet International +32-(0)3-575-5555
NALCO EUROPE B.V. Postbus 627 • 2300 AP Leiden • The Netherlands • +31 71 5241 100
For additional copies of an MSDS visit www.nalco.com and request access
9 / 10
SAFETY DATA SHEET
PRODUCT
EC6449A
Belgium +32-70-245245
Czech Republic +420 224 91 92 93
France +33-(0)145-42-59-59 ORFILA
Hungary +36-80-201-199 ETTSZ, 1096 Budapest, Nagyvárad tér 2
Latvia + 371 67042473
Slovak Republic +421 (0)2 5477 4166
Numbers quoted in the MSDS are given in the format: 1,000,000 = 1 million and 1,000 = 1 thousand. 0.1 = 1 tenth
and 0.001 = 1 thousandth
NALCO EUROPE B.V. Postbus 627 • 2300 AP Leiden • The Netherlands • +31 71 5241 100
For additional copies of an MSDS visit www.nalco.com and request access
10 / 10