1. The document provides details of an exam for the post of Assistant Executive Engineer (Civil) in the Public Works Department including the date of the exam, number of questions, and subjects covered.
2. The first 20 questions were from the subject of English and covered topics like parts of structures, civil engineering works and processes, and basic vocabulary.
3. The full exam had 77 questions testing knowledge across various civil engineering topics like structures, construction materials, soil mechanics, transportation engineering, hydraulics and more.
1. The document provides details of an exam for the post of Assistant Executive Engineer (Civil) in the Public Works Department including the date of the exam, number of questions, and subjects covered.
2. The first 20 questions were from the subject of English and covered topics like parts of structures, civil engineering works and processes, and basic vocabulary.
3. The full exam had 77 questions testing knowledge across various civil engineering topics like structures, construction materials, soil mechanics, transportation engineering, hydraulics and more.
1. The document provides details of an exam for the post of Assistant Executive Engineer (Civil) in the Public Works Department including the date of the exam, number of questions, and subjects covered.
2. The first 20 questions were from the subject of English and covered topics like parts of structures, civil engineering works and processes, and basic vocabulary.
3. The full exam had 77 questions testing knowledge across various civil engineering topics like structures, construction materials, soil mechanics, transportation engineering, hydraulics and more.
Department: PWD Post case number = F4-18/2020-R Test held on = 04/10/2020 First 20 questions were from subject of English.
1. A _________ is a projecting stone which is usually provided to serve as support
for roof truss? Course, Cornice, Corbel or Frieze, None of these 2. The strength of brick masonry in 1:6 c/s mortar is? 50 tonnes/m2 3. To dam up the water in river, structure provided is? Weir 4. The amount of water in stream is called? Run off, streamflow, discharge, all 5. Water falling in any form is called? Precipitation 6. Barrage is? Gated weir to raise water level 7. Thickened part of flat slab is called? Drop panel 8. Soil pipe 9. Yield of catchment? 10. Waste water from kitchen, sink, shower? Sullage 11. Impact load due to moving vehicle during service period is? Toughness 12. Detention period in plain sedimentation tank? 4-8 hrs 13. Lead time is called? 14. Critical path is longest. 15. Steady flow mass inflow w.r.t time= mass outflow w.r.t. time 16. The type of flow where flow parameters changes w.r.t time? steady flow 17. Bernoulli’s theorem is applicable to? Venturimeter, orificemeter, pitot tube, all 18. The distance travelled by a moving vehicle during perception and brake reaction times, is? Sight distance, stopping distance, lag time, none 19. Precedence diagram method? Activity on node, Activity on arrow 20. Principal of survey is to work from? Whole to part 21. The imaginary line passing through the intersection of cross hairs and the optical centre of the objective, is known as? Line of sight, line of collimation, axis of telescope, none 22. Angle between inclined line of sight and horizontal is called? Direct angle, vertical angle, horizontal angle, none 23. A line normal to plumb line is? Horizontal line, level line, datum line, vertical line 24. Time required to perform activity is called? Duration 25. Critical path has? Zero float 26. Pit run aggregates? 27. Peat soil is formed by decaying of organic vegetables. 28. Consolidation and compressibility? 29. Consolidation? Reduces water voids 30. Total float? Latest finish time – early finish time or Latest start time – Early start time 31. TS= TDS+TSS 32. Profit, contingency is? Indirect cost, direct cost, mark up, none 33. Earned value? Budgeted cost of work performed 34. Cost performance index (CPI)? Earned value/ actual cost 35. For decreasing deflection in beam? Increase its depth 36. Equivalent length of fixed columns? 0.5L 37. Maximum deflection in simply supported beam subjected to isolated load? y=Wl3/48El 38. Bending moment is maximum at? Extreme fibers, compressive at top, both 39. Two columns having unequal load, maximum hogging will occur? Where shear is 0 40. Ability of soil to pass water through it is called? Permeability 41. Permanent hardness is due to? Chlorides and sulphates of magnesium and calcium 42. Turbidity is? clarity of water 43. Rigid pavements have? Shallow depths, low modulus of elasticity 44. Manometer is used for? Measuring pressure in pipes and channels 45. Ratio of lateral strain and axial strain is called? Poisson’s ratio 46. Cantilever beam carrying UDL, the bending moment will be? Wl2/2 47. Effective span of simple supported slab? Clear slab dimension+ half the slab depth on either side 48. If two spans of unequal length and unequal loading combines at support then the moment will be? Lesser, greater 49. If the end portion of a beam extends beyond the support, then the beam is known as? overhanging beam. 50. At neutral axis of beam, shear stress is? Maximum 51. Where curvature of bending moment diagram changes sign, it is called? point of contraflexure 52. Survey? base line 53. Maximum super elevation on hill roads is? 10 % 54. Design of cantilever beam is based on? Fixed end reactions 55. Fine particles diameter is? 0.075 mm 56. Reynold’s number is ratio of inertial forces to? viscous forces 57. Deformed bars are called ss due to? Roughness, high tensile strength 58. To retain earth from slippage on hill side? Breast wall 59. Weight per unit volume at specific temperature and pressure? Specific weight 60. Dams are checked for stability? Overturning, tension at base, sliding, all 61. Maximum eccentricity for non-tension is? B/6 62. Moment of inertia of circular section? πD4/64 63. Minimum spacing between horizontal parallel reinforcement of different sizes, should not be less than? One diameter of thicker bar 64. In under reinforced beams? Steel will yield first 65. Lapping of steel is done for? Shear 66. In pavement design, the factors considered? Drainage, traffic load, all 67. Constant traffic speed, constant density, both 68. Covering of external walls? Coping 69. The course laid perpendicular to face of wall is called? Header 70. If intermediate sizes are missing, then the gradation is called? Well, gap, poor 71. In deep beams which bars are provided? Skin, modular, lap 72. In sufficient water in concrete causes? Harsh mix, low workability, both 73. Fine soil has following properties? Have more compressibility, have more voids, may or may not be plastic, all 74. Which one is not correct? Timber is used as bracing in pits, grillage foundation is shallow, none 75. A body is said to be in equilibrium if? Sum of vertical forces= 0, sum of horizontal forces = 0, sum of moment = 0, all 76. At the interference of between two immiscible fluids, forces develop in fluid which the surface has to behave as if it is membrane, this phenomenon is called? viscosity, capillary, surface tension 77. In transition curve? Radius starts from infinity to simple circular curve 78. The water content where reduction in moisture content will result in no volume reduction? Shrinkage limit
Transition and Turbulence: Proceedings of a Symposium Conducted by the Mathematics Research Center, the University of Wisconsin–Madison, October 13–15, 1980