Professional Documents
Culture Documents
SUPPLEMENTARY DATA GH180r6A
SUPPLEMENTARY DATA GH180r6A
SUPPLEMENTARY DATA GH180r6A
Number of phases 3 AC
Input voltage 6.9 kV
Input voltage tolerance +10 %, -5 %1) of nominal rated input voltage
Input frequency Hz 50
Input frequency tolerance +/-5 %
1) Input voltage falls below 90% to 65% of rated value
• output power is rolled-back linearly from 100% power @ 90% input voltage down to 50% power @ 65% input voltage
• output power is reduced by limiting the available motor torque
• continuous operation in this mode possible
The SINAMICS Perfect Harmony GH180 converter system is supplied with an integral isolation transformer which
allows to adapt to line side voltage as a standard solution from 475 V up to 8.00 kV for drives with 9 cells.
Drives with more than 9 cells can be supplied with line side voltage from 2.3 kV up to 13.8 kV.
Because of the unique multi-cell topology design, the SINAMICS Perfect Harmony GH180 converter does not
cause any significant stress on the motor insulation or bearings. The motor side Harmonic Voltage Factor is
below requirements of NEMA MG1-30 standard. Therefore, it is suitable for operation of both new and existing
standard direct-on-line motors.
CONFIDENCIAL 1 / 2
Supplementary data of the Perfect Harmony Drive
Electrical data
2) GH180 drives, when de-rated properly, are available for high frequency applications with de-rated torque.
CONFIDENCIAL 2 / 2