~.. Pure STP
Un Ue RR CRC LU)Waste water treatment has assumed great significance in today's context, where
protecting the environments a prime concern. the main objective of the waste water
treatment is to treat the effluent before it is discharged so that the environment is not
polluted. Waste water treatment in general refers to treatment of suspended and
floatable material, treatment of biodegradable organics and the elimination of
pines nic organisms, The contamination in the waste water. are removed by
sical, Chemical and biological means, these organisms are elisclively remove
by SAAI Pure STP.
Itis a dry free flowing powder contains concentrated source of free flowing hydrolytic
enzymes and ten strains of natural bacteria that are genetically capable of
producing enzymes in waste water treatment systems under aerobic and an aerobic
conditions. It is used for reducing BOD, COD levels as well as reducing the sludge
volumes odoor and color in the effluent Gndsewage treatment plants.
APPLICATION
THIS PRODUCT FINDS APPLICATION IN INDUSTRIES LIKEADVANTAGES
> Sludge volume will be reduced more, as more solids are digested.
» Remove bad odor.
> Sludge will be easier to pump, process and dewater and will have less odor foo.
> The capacity of the system will be effectively increased, because more waste
can be processed, more effectively in, in less time.
» Easier to balance the treatment system.
> Bacterial oxidation of the liquid phase will be faster and more complete.
> Digesters will operate evenly and uniformly, easier planning and routine waste.
DOSAGE RECOMMENDATIONS
The areas in which SAAI Pure STP, is used are
» Oxidation lagoons
» Sludge pits
> Grease taps
» Aeration tanks
La lanlatelimrelaLey
» Digesters
» Septic tank
» Clarifiers
> Trickling filters
FLOW CHART
TREE LCE
cert ailias
SAM cS Mae SLL La a ka
ere Ronn
Oxidation tank Gbapeatescn
SUNSET Dewatering process
DSi sertany ret
BSC me COE
Dosage rate will vary with retention times BOD / COD ranges, water temperature,
PH, sludge build up and pond depth.> For one lakh litres of effluent, use 20PPM i.e 2Kg of enzymes per F
FSF BE SISEnaHTS Save USsaGS Hom MikecePoeares wey Rie OSPPM
ie 500gprintino pure stp.
> Normal preventive maintain rates are based on the following criteria.
> Minimum retention time of 5 days
> BOD ranges of 150000 - 40ppm.
> PH of 3-12.
NOTE
The product is to be used in a waste treatment system with a continuous flow
and hydraulic retention of less than 24 Hrs. The products may be soaked in luke
warm water at 30 C for 8hrs in 1 % water solution to activate the biological
components and to allow the bacteria to get a start. Soaking period of over
10-12hrs is recommended.
In multiple level applications it is recommended to dose at the lowest level first.
The point of application should be in an area which allows the product maximum time
inthe system.
DIRECTIONS FOR USE
It should be activated by mixing them in a bucket of warm water for few minutes.
Pour the slurry into the system at point where normal water flow will disperse it evenly.
The best way is to pour it into the waste stream inside the plant or just before it flows
out into the plant / pourit directly into the middle of the pond or around the perimeter.
Bad odours and sludge accumulations take months and years to build up, and it
will take some time to get rid of them, begin the treatment with double the weekly
normal dosage for a period of 3-4 weeks, after seeing a significant improvements
and can cut back to normal weekly dose. Severe accumulation of sludge
may take one / more years to get eliminated.APPEARANCE
Off white color free flowing Powder / Liquid
SPECIFICATION
Aerobic bacteria: Not Less than 50 billion colonies/g
Anaerobic bacteria: Not Less than 50 billion colonies/g
Facultative bacteria: Not Less than 50 billion colonies/g
Total plate count: Less than 6.0 billion colonies/g
Multi Enzymes: O6LakhU/g (Protease, Amylase, Lipase etc.)
E. Coli: Absent/1g
Salmonella: Absent/25g
Toxins: Absent/1g
STORAGE
Keep in dry storage area under 45 Degree Celsius.
OPERATIONAL PARAMETERS
Heavy metal concentration should be maintained less than 20ppm.
Safety :
Rinse thoroughly with water in case of contact with skin or mucous,
membranes in case of allergy, seek medical attention.
NaS lest
a F ml oy
Cees
Eisen ers akoS f\ f\ ELECTRO BIOGENIC
INDIA PVT LTD
Always there for care
‘CORPORATE & MARKETING OFFICE:
{G3A. VW Koll Street, Thiruvalleswarar Nagar, Thirumanglam, Annanagar(West), Chennai - 600040,