Professional Documents
Culture Documents
CES 5.1 5.2 Operational Level TEST 11.Pd Compressed
CES 5.1 5.2 Operational Level TEST 11.Pd Compressed
What are the required data inputs into most gyro compasses to reduce any
possible compass error?
SELECT ANSWER:
I don't know
Qy Enlarge
QUESTION 1 OF 81
Having a CO2 alarm during normal working hours, what immediate action
should be taken?
SELECT ANSWER:
I don't know
Q. Enlarge
QUESTION 2 OF 81
What corrections must be applied to the echo sounder reading to compare the
depth of water with the depth printed on the chart?
SELECT ANSWER:
I don't know
Q. Enlarge
QUESTION 3 OF 81
ESPLOSIVE
AREX
%Oxygen content
I don't know
Qy Enlarge
QUESTION 4 OF 81
You are sailing in shallow water with a 15% Under Keel Clearance. Turning the
ship around, what space do you need compared to deep water?
SELECT ANSWER:
Ls
The turning diameter of your ship is the same for all water depths
I don't know
Q. Enlarge
QUESTION 5 OF 81
SELECT ANSWER:
I don't know
Qy Enlarge
QUESTION 6 OF 81
SELECT ANSWER:
20 bar
160 bar
I don't know
Qy Enlarge
QUESTION 7 OF 81
SELECT ANSWER:
Ls
On the number of kilobits of information transmitted per block of 1024
bits
I don't know
Q. Enlarge
QUESTION 8 OF 81
SELECT ANSWER:
I don't know
Qy Enlarge
QUESTION 9 OF 81
SELECT ANSWER:
Crude Oil
Fuel Oil
I don't know
Qy Enlarge
QUESTION 10 OF 81
SELECT ANSWER:
S
The fore and aft Centreline is indicated by D, in the figure
I don't know
Q. Enlarge
QUESTION 11 OF 81
SELECT ANSWER:
Start, operate and stop main and auxiliary machinery units, including
switching between automatic, remote and/or manual control functions,
and operate the various units in various modes.
I don't know
QUESTION 12 OF 81
SELECT ANSWER:
NCU-720/720
MP / HF Radio Equipment
\ NFC-700
Antenna Tuner
I don't know
Q. Enlarge
QUESTION 13 OF 81
If the radar is set onto the Relative Motion Display, what would an echo of a
target with no trail indicate? Note this the trail of the echo and not a vector.
SELECT ANSWER:
I don't know
Q. Enlarge
QUESTION 14 OF 81
SELECT ANSWER:
Ls
The aircraft is short on fuel and is returning to base.
I don't know
Q Enlarge
QUESTION 15 OF 81
What immediate actions should the Officer of the Watch take when the ship
goes aground on an uncharted shoal in the middle of the ocean?
SELECT ANSWER:
Stop engines and tell the engine room to switch over to high suctions
I don't know
Qy Enlarge
QUESTION 16 OF 81
7% Oxygen
21% by volume.
I don't know
Q. Enlarge
QUESTION 17 OF 81
SELECT ANSWER:
Always carry a walkie talkie with you into the pump room and call for
help immediately if you start feeling dizzy
I don't know
Q. Enlarge
QUESTION 18 OF 81
SELECT ANSWER:
I don't know
Qy Enlarge
QUESTION 19 OF 81
SELECT ANSWER:
Channel 16 only
Channels 13 & 16
Channels 6 & 16
I don't know
Q. Enlarge
QUESTION 20 OF 81
ae of the follo wing figures dr awn on the Hine of the Meridian is correct for
"West, when
obser any the sun on 1 the meaHaSae ifthe s sun's s De clination i is 15°00' South?
SELECT ANSWER:
N-POLE Zenith sd Zenith
Figure 3 is correct.
5 5 Horizon Horizon
Figure 1 is correct.
Horizon Horizon
Figure 2 is correct.
I don't know
Q Enlarge
QUESTION 21 OF 81
SELECT ANSWER:
I don't know
Qy Enlarge
QUESTION 22 OF 81
If an electrical storm strikes in the vicinity of the ship whilst conducting oil
transfer operation, the OOW should:
SELECT ANSWER:
Maintain a close check on inert gas content in the ships tanks, but
continue the cargo transfer.
I don't know
Q\ Enlarge
QUESTION 23 OF 81
SELECT ANSWER:
The draught of an iceberg is about the same as the visible part of the
iceberg above the water.
Ls
The depth of an iceberg below the surface is always about one sixth of
its total depth.
I don't know
Qy Enlarge
QUESTION 24 OF 81
SELECT ANSWER:
I don't know
Q. Enlarge
QUESTION 25 OF 81
SELECT ANSWER:
This is a fishing vessel, not making way through the water, with its
nets fast upon an obstruction, seen from astern.
I don't know
Qy Enlarge
QUESTION 26 OF 81
SELECT ANSWER:
Destination.
I don't know
Q Enlarge
QUESTION 27 OF 81
SELECT ANSWER:
I don't know
Q. Enlarge
QUESTION 28 OF 81
SELECT ANSWER:
2 years
6 months
I don't know
Q. Enlarge
QUESTION 29 OF 81
SELECT ANSWER:
I don't know
Qy Enlarge
QUESTION 30 OF 81
DSC uses for automatic identification the MMSI. The identification 002442000 is
ssigned to:
SELECT ANSWER:
NCU-720/720
MP / HF Radio Equipment
A group of vessels
\ NFC-700
Antenna Tuner
A type of vessel's
A vessel
I don't know
Q. Enlarge
QUESTION 31 OF 81
What are the main components causing the magnetic compass to require a
regular evaluation and compass correction?
SELECT ANSWER:
I don't know
Qy Enlarge
QUESTION 32 OF 81
During Crude Oil Washing, those areas of the cargo tank which are not directly
struck by the oil jet from the tank washing machines are referred to as:
SELECT ANSWER:
INERT GAS
PIPE |
Protected areas.
Hidden areas.
Deflected areas.
I don't know
Qy Enlarge
QUESTION 33 OF 81
SELECT ANSWER:
NCU-7120/720
144 Ah MEF/HF Radio Equipment
NFC-700
Antenna Tuner
I don't know
Q. Enlarge
QUESTION 34 OF 81
What do you call the method used for bone-soft part injuries?
SELECT ANSWER:
ABC-method.
REHAB-method.
I don't know
Qy Enlarge
QUESTION 35 OF 81
SELECT ANSWER:
The ship should steer about 100 degrees of the prevailing weather
and sea with the boat to be launched on the leeside.
The ship should lie stopped in the water with the weather on the
opposite side to the boat to be launched
The ship should steer with the prevailing weather and sea on the
beam and the boat to be launch on the leeside.
I don't know
Q. Enlarge
QUESTION 36 OF 81
What is the shortest distance between two points on the surface of the earth?
SELECT ANSWER:
Small circle
Rhumb line
I don't know
Qy Enlarge
QUESTION 37 OF 81
A ship in distress s hould transmit the appropriate alarm signal followed by the
distress call and message on one or all of the international distress frequencies.
Which of frequencies is in accordance with the present recommendations
SELECT ANSWER:
I don't know
Q Enlarge
QUESTION 38 OF 81
is the name given to the special list of cargo loaded on board a ship that
to be prepared for reporting and other administrative purposes?
SELECT ANSWER:
Tally list.
Load Summary.
Stowage Plan.
I don't know
Q. Enlarge
QUESTION 39 OF 81
SELECT ANSWER:
I don't know
Q. Enlarge
QUESTION 40 OF 81
indicate that you have a very urgent message to transmit concerning the safety
of another vessel or person?
SELECT ANSWER:
I don't know
Qy Enlarge
QUESTION 41 OF 81
The distress message is used when the vessel is threatened by a serious and
imminent danger and is in need of immediate assistance. What is the
telegraphy and telephony distress message like?
SELECT ANSWER:
I don't know
Qy Enlarge
QUESTION 42 OF 81
Which of the connections you are shown, are the dedicated shore connection
(MARPOL-connection) for discharging of sewage ?
SELECT ANSWER:
I don't know
Q. Enlarge
QUESTION 43 OF 81
As per SOLAS the Inert Gas System of an oil tanker must deliver the inert gas
with a maximum level of oxygen of:
Maximum 3% by volume. ; l |
I don't know
Qy Enlarge
QUESTION 44 OF 81
The transmitting receiving method, when both stations can transmit and
receive at the same time is called:
SELECT ANSWER:
Semi-duplex
Simplex
I don't know
Q. Enlarge
QUESTION 45 OF 81
SELECT ANSWER:
. 5 5 : NCU-710/720
Send no PDN’s with messages intended for the mailbox ME/HF Radio Equipment
NFC-700
Antenna Tuner
Not send any PDN for this message
I don't know
Q. Enlarge
QUESTION 46 OF 81
SELECT ANSWER:
Ls
Outline specific measures for your ship to move from security level 1 to
2 and from 2 to 3.
I don't know
Q. Enlarge
QUESTION 47 OF 81
SELECT ANSWER:
I don't know
Qy Enlarge
QUESTION 48 OF 81
SELECT ANSWER:
Ve.
I don't know
Q. Enlarge
QUESTION 49 OF 81
SELECT ANSWER:
Special radar
10 Cm radar
I don't know
Q Enlarge
QUESTION 50 OF 81
SELECT ANSWER:
I don't know
Q. Enlarge
QUESTION 51 OF 81
What is the most important way to contain small oil-spills from cargo
operations on the ship?
SELECT ANSWER:
"Oil on deck"
Have sawdust located by the manifold
Have Sandpiper pumps rigged on the aft part of the tank deck
I don't know
Qy Enlarge
QUESTION 52 OF 81
SOLAS requires the tank coatings in dedicated seawater ballast tanks on oil
tankers to be of:
SELECT ANSWER:
I don't know
Qy Enlarge
QUESTION 53 OF 81
SELECT ANSWER:
Cargo tanks which may be used for ballast, where the lines are not
connected to the Oil Discharge Monitoring Equipment
[3
Cargo tanks which may be used for the carriage of ballast
Cargo tanks which each have their own individual pumps, are fitted
with independent piping systems and are served by unconnected
ventilation arrangements
I don't know
Qy Enlarge
QUESTION 54 OF 81
If the flow of gas to shore reaches the maximum declared capacity whilst using
the Vapour Emission Control System (VECS), the OOW should:
SELECT ANSWER:
Open the mast riser vents to relieve the excess pressure and bring the
flow within the declared range.
I don't know
Qy Enlarge
QUESTION 55 OF 81
Under GMDSS which VHF channel is used for Digital Selective Calling (DSC)?
SELECT ANSWER:
Ch.16
NRE-63/NKG-52
DSC WATCHKEEPING
RECEIVER & PRINTER
I don't know
Qy Enlarge
QUESTION 56 OF 81
When a ships derrick or crane lifts a weight off the deck of a ship, from which
position can the centre of gravity of the weight be considered to act?
SELECT ANSWER:
From the position on the deck from which the weight was lifted
I don't know
Qy Enlarge
QUESTION 57 OF 81
STCW/Deck/Operational/Oil Tanker
QUESTION ID: U6pt2HHM
What are the immediate duties of the bridge Officer of the Watch when the ship
suddenly runs into a fog bank?
SELECT ANSWER:
Commence sounding the fog signal and reduce speed to Slow Ahead
N - Fog Bank
Commence sounding the fog signal and call the Master and wait for
him to arrive before taking any further actions
I don't know
Qy Enlarge
QUESTION 58 OF 81
STCW/Deck/Operational/Oil Tanker
QUESTION ID: clJKdhyw
SELECT ANSWER:
I don't know
Qy Enlarge
QUESTION 59 OF 81
The positions of the ship provided by the GPS should always be confirmed by
other means, when possible. Which of the following suggested methods would
be the most accurate?
SELECT ANSWER:
Ls
Bearing using the Radio Direction Finding of three radio beacons
I don't know
Q. Enlarge
QUESTION 60 OF 81
SELECT ANSWER:
I don't know
Qy Enlarge
QUESTION 61 OF 81
After completing all pre-starting checks on the flue gas plant, the first thing that
the operator would do is to:
SELECT ANSWER:
I don't know
Q. Enlarge
QUESTION 62 OF 81
SELECT ANSWER:
A crude oil cargo which has left substantial residues in the bottom of
the tank after discharge.
I don't know
Qy Enlarge
QUESTION 63 OF 81
What is the minimum Initial Transverse Metacentric Height (GM) allowed under
the International Load Line Rules?
SELECT ANSWER:
0.5 metres
1.0 metre
2.5 metres
I don't know
QUESTION 64 OF 81
STCW/Deck/Operational/Oil Tanker
QUESTION ID: Z83zsIt0
In context of cargo oil depth and ullage measurements, the abbreviation UTI
stands for:
SELECT ANSWER:
I don't know
Qy Enlarge
QUESTION 65 OF 81
SELECT ANSWER:
Decrease the speed and keep the ship to the centre of the channel
where the water is probably deepest
Enter the shallow water with a stern trim and proceed at a moderate
speed.
Maintain a speed of about six (6) knots and use minimal rudder when
manoeuvring
I don't know
Q. Enlarge
QUESTION 66 OF 81
SELECT ANSWER:
Ls
Close rescue boat ventilation aperture
Open hatches
I don't know
Q. Enlarge
QUESTION 67 OF 81
What is correct UTC in this example? Approx. Pos: N49°51' W35°23', zone +2,
Local Time 0900.
SELECT ANSWER:
I don't know
Q. Enlarge
QUESTION 68 OF 81
SELECT ANSWER:
LS
Continuously after having been immersed for a period of 1 minute
under 1m of water
I don't know
Qy Enlarge
QUESTION 69 OF 81
SELECT ANSWER:
The correct form of response would be: "I am using the 3 cm radar"
The correct form of response would be: "I am using the largest range
scale”
The correct form of response would be: "I am using the 10 cm radar”
I don't know
Q. Enlarge
QUESTION 70 OF 81
SELECT ANSWER:
I don't know
Q. Enlarge
QUESTION 71 OF 81
SELECT ANSWER:
I don't know
Q. Enlarge
QUESTION 72 OF 81
Sellcall Routine
SELECT ANSWER:
NCU-720/720
VHF- channel 16 MP / HF Radio Equipment
NFC-700
Antenna Tuner
Radio telephony-channel 7 in the 8 MHz band
I don't know
Q. Enlarge
QUESTION 73 OF 81
SELECT ANSWER:
A green light on the starboard side and red light on the port side,
showing an unbroken light over an arc of 135 degrees, from right
ahead to 22.5 degrees abaft the beam on the respective side.
I don't know
Qy Enlarge
QUESTION 74 OF 81
What is a “consign
SELECT ANSWER:
[3
Any person or company which seeks to transport a consignment of
cargo by sea.
I don't know
Q. Enlarge
QUESTION 75 OF 81
Crude Oil Washing of a cargo tank using oil containing substantial amount of
water could result in:
SELECT ANSWER:
BN
OI 4
SUPT
. a 7 ik
Caer
I don't know
Q. Enlarge
QUESTION 76 OF 81
SELECT ANSWER:
Ls
Finding the conversion factor to convert volume in US barrels (bbls) to
cubic metres.
I don't know
Q. Enlarge
QUESTION 77 OF 81
Tanks lids and other access points on an oil tanker are usually shaped round so
as to:
SELECT ANSWER:
Avoid injuries to crew members from the sharp ends of such openings.
Allow several people to have visual access to the tank at the same
time.
I don't know
Qy Enlarge
QUESTION 78 OF 81
SELECT ANSWER:
Halogenated Sulphide.
Hydrogen Separation.
I don't know
Q. Enlarge
QUESTION 79 OF 81
Ballot's Law”
pressure area be located?
SELECT ANSWER:
Straight ahead
I don't know
Qy Enlarge
QUESTION 80 OF 81
Where would you find out which fire sections are enclosed by "A" or "B” class
divisions on a ship?
SELECT ANSWER:
I don't know
Qy Enlarge
QUESTION 81 OF 81