Professional Documents
Culture Documents
Power Convertor Maintenance and Operation Instuction
Power Convertor Maintenance and Operation Instuction
(22V--30V) voltage can be transferred by internal voltage isolation to stable output DC voltages. The high
output power can work normally under -25℃~+50℃ environment temperature, possessing good properties
for damp proof, shockproof and shocking resistance, satisfy the requirements of electromagnetic compatibility.
The DC power supply contains three groups: input filter, a zero voltage switching (ZVS) isolated
The input and output DC power both lower than human body's safe voltage. Safety is absolutely ensured.
The DC power supply's shell adopts Tunnel air cooling structure, metallic shielded by six surface of
shells. Wall installation for power devices and heat dissipation. Internal entity package protect against moisture,
A2: 220*160*60
孔 距 : 180*152
160 孔 径 : 4-φ 4.5
单 位 : (mm)
3 Technical features
a) Input voltage:DC10V~16V;
1
b) Polarity protection for input voltage。
c) Overheating protection shut-off: the DC power supply need to be recovered to normal temperature,
e) DC output short circuit protection: automatic recovery, not support short circuit for long time.
f) DC output over voltage protection: shut-off, reenergize the power supply after removing the over
current faults.
adjustable)
Storage temperature:-30℃~+55℃
I) Insulation resistance:
Dimensions: 180mm*152mm
2
5 Installing and Debugging
DC power supply's installation: The supply's bottom mounting hole should be fixed with the installed
body's screw. The high output power requires good ventilation cooling environment, which can give a longer
life and performance to power supply. Choose suitable install position is very necessary.
DC power supply is adjusting free one which adjusted before the factory.
For reliable operating of DC Power Supply, please use and operate it under the following methods:
a) Check the correction of input signal polarity, no circuit fault of output load, fasten terminal block
b) During operating the input voltage shall be checked to be within nominal range and input current is
c) Pay attention to ventilation for heat elimination if the supply operating for long-time;
d) The DC power’s operating current should under the 80% of maximum current, super burden and
e) Make sure the input power and output power shortened before testing insulation resistance for
avoiding damage.
TEL:0421-2732351
Address:No446, LuoYu Road, Hongshan District, Wuhan City, Hubei Province, China
TEL:027-87452731
FAX: 027-87506800
3
Contact: GUO ZHU ZHANG
E-mail:cydy4nic@163.com
Http//www.4nic.com.cn