Professional Documents
Culture Documents
Instructions On AccuMark Plot Pieces by Lectra Alys Plotter
Instructions On AccuMark Plot Pieces by Lectra Alys Plotter
Gerber Technology
28 February 2007
Page 1 of 5
General
• In this example, Accumark is loaded on one PC (PC1), and the Alys drivers plus
the Lectra “Just Print” application are loaded on a second PC (PC2). As noted
below, in some cases it may be necessary to also install the Lectra Alys Pilot
Explorer program.
• A “Z:” drive is created by mapping from PC1 to PC2 using the path:
\Lectra on PC2. (\Lectra is a folder on PC2 that contains a sub-folder named
PLOT.) This can actually be any path since we will tell the Lectra plot program
where to find the file.
• PC1 is connected via network (this can also be direct) to an Infinity plotter with a
destination = “Serv”. PC2 is connected directly via USB to the Alys.
• For plotting pieces, run Piece Plot, change the Plot Destination to DOS FILE, then
open Plot Options to change the File Type to HPGL and use plt for the extension
name, and use Z:\PLOT for the Default Directory.
• For plotting markers, run Marker Plot, change the plot destination to DOS FILE,
then open Plot Options and change the file type, extension and default directory
using the same details as specified in the Piece Plot Options.
Page 2 of 5
Configuring the Alys Plotter
This section will explain how to configure the Alys Plotter. If your system is already
configured with the Alys plotter, please ignore this part and go to “Plot HPGL file in PC2
on Alys”.
• Then please follow the Configuration Assistant to finish the driver installation.
• After finished driver installation, it will prompt the current device. Below is the Alys
plotter connected via a USB cable:
Page 3 of 5
Once the installation is finished, this icon will be on your desktop.
When you press Plot, the selected HPGL file will be sent to the job queue as shown below:
Page 4 of 5
In some Lectra configurations, the First Alternative described above does not work. In
such a case, it may be necessary to use an optional Lectra licensed program named the
Alys Pilot Explorer. The following instructions assume that the Alys Pilot Explorer has
been installed and is properly licensed by Lectra:
• Choose the Icon for “Alys Pilot Explorer”
• At program screen, click “Add”
• The HPGL folder (or whatever folder your path was mapped to) will show the
available pieces/markers in HPGL format. Select the piece(s)/marker(s) you want
to print.
• Make sure the Alys is On Line and the paper is loaded.
• Click “Plot”
Page 5 of 5