Professional Documents
Culture Documents
Des10 7
Des10 7
Des10 7
CHAPTER VII
SITE INVENTORY
The images below offered by the researcher are the current condition of the site. The
researcher made an ocular on the site, roamed the general part of the New Bilibid Prison. The
researcher also conducted her walkthrough in the vicinity near in the subject area. The
images below are the building structures, roads, landmarks, and etc. within 1-2 km. radius
The site for the proposed project is situated in the Barrio of Poblacion, Muntinlupa City.
Climate Analysis
where it is characterized by the two pronounced seasons: rainy season from May to October
Table 7.2. shows the Climatological Normals gathered by the station situated in NAIA,
Pasay City. The figures represent the averages as indicated by the subheadings from 1981 to
2010, which also depict the situation in the southern part of Metro Manila including Muntinlupa
City. Muntinlupa has a hot, humid weather all year round with average relative humidity of 76%,
although, it is generally cooler between the moths of November and February. The hottest
month is May when the temperature averages 28ºC. The rainy season is between June and
October, although some precipitation is possible throughout the year. The average annual
rainfall is approximately 2,000 mm with a peak of at least 400 mm in August and low of 4 mm in
The future projections for the years 2020 and 2050 under the medium- range emission
scenario for Metro Manila. The climate change data derived from tables are the seasonal
temperature increase in ºC, the seasonal rainfall change in %, and the frequency of extreme
events. The tables also show the projected summary of climate changes and their effects on the
seasonal patterns.
Table 7.2.
Climatological Normals (Temperature)
Period: 1981- 2010
Rizal Technological University
College of Engineering, Architecture and Technology 168
Department of Architecture
Maximum rainfall in Muntinlupa City occurs from the month of June to October. The
annual amount of rainfall is 1,767.8 millimeters with a peak of 418.4 millimeters in August and a
Temperature
The annual mean temperature reading for Muntinlupa is 27.8ºC. The highest
temperature occurs during the months of April and May (33ºC- 34ºC), while the lowest occurs
Humidity
The relative humidity of Muntinlupa City has an annual average of 76%. This makes the
city better than the municipalities of Laguna, which has an average relative humidity of 81%.
Typhoon
The Philippines, due to its geographical location is one the Asian countries often
affected by typhoons. It is located within the so- called “typhoon belt”. Generally, typhoon
season starts from June and ends in November. However, the rest of the months are not
entirely free of the typhoon since they are unpredictable in nature and might enter the country
anytime of the year. The mean percentage frequency of typhoon passage over the
Rizal Technological University
College of Engineering, Architecture and Technology 169
Department of Architecture
Metropolitan Manila of which Muntinlupa is a part, ranges from 11% to 20%. Albeit, 3 to 5
The wind direction from October to March, prevailing winds blow easterly, while the rest
of the months have winds blowing westerly.
Northeast Monsoon (Amihan) and Southwest Monsoon (Habagat) can directly hit the
site. The location of the project is open for winds in all direction.
The site is open to direct exposure of sunlight all sides because there is no high
Based on the image of traffic flow from the Google map, the road inside the site has a
fast traffic flow (Muntinlupa- Cavite Expressway). The researcher also evaluate the site, and it
Rizal Technological University
College of Engineering, Architecture and Technology 170
Department of Architecture
has roads inside the site, NBP Road, Sampaguita Road which have a fast traffic flow. The site
has no problem in terms of traffic flow inside the project site. Although the proposed project
has the potential to create traffic in the future, the site has an entry road lessen the traffic
congestion and a drop of area should be considered to eliminate traffic in the vicinity.
CIRCULATION ANALYSIS
Based on the Figure 7.22. of circulation from the Google map, there is a road inside and
beside the site the Muntinlupa- Cavite Expressway (MCX), beside the project site there is a read
that can be accessible to the site the Daang Hari Road on the west part of the project site.
Rizal Technological University
College of Engineering, Architecture and Technology 171
Department of Architecture
PROXIMITY ANALYSIS
Structures, existing roads and landmarks are shown in the Figure 7.23. within 1
kilometer radius form the project site. But these building structures are not complimentary for
SENSORY ANALYSIS
Sound Analysis:
Rizal Technological University
College of Engineering, Architecture and Technology 172
Department of Architecture
The noise contributor in the site are the vehicles that passing through the road via
Muntinlupa- Cavite Expressway (MCX) and from the Daanghari Road. The noise coming from
the people inside the perimeter of the project and from the roads inside the site can contribute
noise.
The views can be seen and characterized as a place where peace and serenity lives.
Smell Analysis:
The smell of the environment at the site is fresh because it surrounds by a lot of
The project site was classified by the City Government as Planned Unit Development
(PUD). The location of property of the project site is under New Bilibid Prisons and the owner of
showing at the minimum, proposed land uses, building density and bulk, road network layout,
road and sidewalk section details, and master layouts of all utilities such as those for potable
water, storm drainage, sewerage, power supply, telecommunication and solid waste
management.
The proposed CMDP shall properly referred to the City (in case any private proposal is
submitted) and approval of the said plans by the City Council shall be required. CMDPs shall
also provide with Deed of Restrictions where, upon approval of the Zoning Administrator/ Zoning
Officer or Local Zoning Board of Appeals (LZBA), as the case may be, proof of compliance of
future projects on the said PUD site shall form part of the requirements for Locational
Clearance. The PUD shall at least observe the following restrictions and regulations:
1. Preservation and maintenance of the natural environment and resources in the area as
control and drainage system, garbage collection and disposal system, etc.
6. Allotment of proper roadway and pedestrian sidewalk with provision for plant strip.
7. Allotment of adequate parking with provision for future expansion as the need arises.
Rizal Technological University
College of Engineering, Architecture and Technology 179
Department of Architecture
SITE EVALUATION
Figur
e 7.30.
Geography
1. The site is located within the Muntinlupa- Cavite Expressway and beside the Daanghari
Road.
2. Geographically located within 14º 22’ 54.80” N latitude and 121º 01’ 47.43” E longitude.
Daanghari Road, by Malipay III in the west, Magdaong River in the south, bounded on
the southeast by Brgy. Tunasan and in the east is along Susana Height Road.
Topography
1. Classified as relatively flat sloping towards the east part of the site.
Suitability
The project is located at NBP Reservation Poblacion, Muntinlupa City as per zoning by
categorized as residential land (R-19) but its actual use is Actual National Government (ANG).
Rizal Technological University
College of Engineering, Architecture and Technology 181
Department of Architecture
Visibility
The site is not as visible as other building structures for security purpose.
Accessibility
The site is accessible but there is a high security standards to be accessible for the
Figure 7.31. Muntinlupa- Cavite Expressway (MCX) which connects Southern Luzon
Expressway (SLEX) and Daanghari Road beside the Project Site that is adjacent to the
site.
Expressway (SLEX) and the Daang Hari Road, has recently been completed. Travel time to and
from Cavite area will now be shortened, this is viewed as a major development. It is also
adjacent to NBP Reservation are several prime residential areas. Given this scenario and the
current development on the outskirts of NBP, it is possible that the envisioned development of
the area will push through. There are also a minor roads inside the site and adjacent to the site,
Rizal Technological University
College of Engineering, Architecture and Technology 182
Department of Architecture
i.e. Insular Road, on the main entry from the site, the Sampaguita Road adjacent to the security
Parking Availability
The researcher provides parking spaces for the employees and visitors of the proposed
project and for the existing parking areas the researcher develops the allotted spaces for the
Traffic Counts
The site has no problem in terms of traffic flow inside the project site. Although the
proposed project has the potential to create traffic in the future, the site has an entry road to
lessen the traffic congestion and a drop of area should be considered to eliminate traffic in the
vicinity.
Rizal Technological University
College of Engineering, Architecture and Technology 183
Department of Architecture
Figure 7.32.
Rizal Technological University
College of Engineering, Architecture and Technology 184
Department of Architecture
Figure
7.33. Transfer Certificate of Title No. 17819 (Page 2 of 3)
Rizal Technological University
College of Engineering, Architecture and Technology 185
Department of Architecture
SITE MAPS
TECHNICAL STUDY
Dormitory
Classification of Dormitory
Type A Dormitory – above 500 inmate capacity and lot area of more than 1.5 hectares
Type B Dormitory – 101 to 500 inmate capacity and lot area of 1.5 hectares
Type C Dormitory – 1 to 100 inmate capacity and lot area of 3,000 sq. m.
A. Dormitory
C. Hospital/ Infirmary
C.5. Dental
C.6. Laboratory
C.9. Beddings
C.10. Pharmacy
F. Workshop Facility
H. Visiting Area
I. Conjugal Rooms
Water design computation must include inmates, prison personnel and visitors. It must be
sufficient to meet the following: Drinking water; Preparation of meals; Maintenance of personal
hygiene; Operation of the sewage and waste-disposal system; Cleaning of premises; Livelihood,
K.1.Dormitories for inmates – For Type A, it shall be a two (2) storey up to four (4) storey
building to accommodate 501 to 1000 inmates and for Type B, a two (2) storey building to
K.8. Water Tank (20,000- gallon capacity with stand-by generator set);
M.1. Dormitories for inmates – For Type A, it shall be a two (2) storey up to four (4) storey
building to accommodate 501 to 1000 inmates and for Type B, a two (2) storey building to
M.8. Water Tank (20,000- gallon capacity with stand-by generator set);
N. Court Room
BILIB IT: The National Institute for Reformation and Rehabilitation, A High- Risk Insular
Prison and Infirmary in Muntinlupa City “A Proposed Redevelopment of New Bilibid Prison
B. Type of Project
Institutional
C. Overview Summary
Congestion or prison overcrowding is not just a national issue but a worldwide issue as well.
Prisons, in most parts of the world are overcrowded where the prison cells accommodate more
than its ideal capacity. This seeming condition does not contribute to the effective rehabilitation
of convicted persons. In year 2013, the Republic Act No. 10575, otherwise known as the “The
Bureau of Corrections Act of 2013” was implemented to New Bilibid Prison (NBP) — one of the
premier prisons in the Philippines, for the purpose of prescribing and applying the necessary
rules and regulation for strengthening of the correctional. The state shall provide for the
upgrading its facilities, increasing the number of its personnel, upgrading the level of
qualifications of their personnel and standardizing their base pay, retirement and other benefits,
making it at part with that of the Bureau of Jail Management and Penology (BJMP). With this,
BILIB IT will have a big help to achieve its purpose. The proposed redevelopment of New Bilibid
Prison is the solution to achieve these goals. Through BILIB IT, this redevelopment will be the
new perspective of NBP in promoting standard safety, security, ease of supervision and
circulation. It will also give the inmates in becoming a better person, having a new hope, new life
while inside the prison. BILIB IT will promote quality rehabilitation and reformation, by providing
normative (less- institutional, more residential like) and spatially stimulating living environment
design and style on how facility design reflects philosophies in correctional movements through
but preventing connivance with each other was thought to lead to self-reflection and remorse
Rizal Technological University
College of Engineering, Architecture and Technology 192
Department of Architecture
and ultimately, to moral elevation with the principle of keeping prisoners in solitary confinement.
The project ensure rehabilitation programs are made available to the inmates for their physical,
intellectual and spiritual development, develop livelihood programs to assist inmates earn a
living and develop skills while in prisons. This comprise adequate living spaces and facilities and
address the basic needs of convicts incarcerated in the existing penal facilities.
The site is located within the Muntinlupa- Cavite Expressway and beside the Daanghari
Road. Geographically located within 14º 22’ 54.80” N latitude and 121º 01’ 47.43” E longitude. It
is bounded in the north by part of Katarungan Village I, in the northwest by part of Daanghari
Road, by Malipay III in the west, Magdaong River in the south, bounded on the southeast by
E. The Proposal
There are two considered inland water bodies in the site, the Jamboree Lake and the NBP
Dam. Jamboree Lake is the most developed as it is one of the promoted tourist attractions in the
site. The project site has a good air because of the trees surrounded in the site.
F.1. Undertaking a massive greenery program to facilitate more avenues for carbon capture
F.2. Vertical gardening in major thoroughfares and heavy commercial areas using pollution
resistant species