Professional Documents
Culture Documents
英文电气操作说明书
英文电气操作说明书
英文电气操作说明书
Electronics
Model: LSBLGF140S-F
CATALOG
1.PANEL INSTRUCTION
2. CIRCUIT PROTECT
3. PREPARING
4. OPERATION
Note:if there are difference express between the Chinese versin and the English
version,the Chinese version is final.
1
Operation Specification
ⅠPanel instruction
1. Alarm-stop switch
Ⅱ Circuit protect
This unit adopts PLC and HMI., which can show all working parameters. When
1. The water pump signal is interlinking edited in PLC, when the pump stops, the
2. QF is for overload and short circuit protect, when the short circuit or the
3. OW is for the oil level protection of the compressor,when the oil level of the
compressor is lower than assess value, the compressor will stop. And the fault lamp of
the PLC will be on, the HMI will show this as well.
pressure is higher than assess value, the compressor will stop. And the fault lamp of
the PLC will be on, the HMI will show this as well.
5. SP is for the pressure protect. When the pressure of the system is too high or
too low, the compressor will stop. And the fault lamp of the PLC will on, the
6. SA is the alarm-stop switch, when the emergency happens, press the button or
7. 1ST is the intelligence protector, it includes the voltage protection, exhaust and
over temperature protection, when the faults happen, the light on PLC will be on.
9. Unit allocates Electrical Source Protection Relay use for special purpose.
2
Attention: when the compressor stop for above reasons, we should smooth
away them. And reset the protectors. Press the buttons in the HMI. When the
Ⅲ Start-up prepare
1. Check the inline , only when the run lamp in the voltage detector is on , the
2. Check the inputs and the corresponding lights in PLC are all on .
3. Check the line and when they are loosen, tighten them.
5. Check the connecting cable between the HMI and the PLC
This unit adopt the HMI, all of the work can be done according to the infer in
the HMI.
Preset the temperature in the HMI, open the switch, the unit will run automatic
1. When the power on, the main menu will first display, as figure 1 shows.
3
figure 1
figure 2
4
figure 3
When the unit has faults, the HMI will show the reasons, press the button of
ALARM, and the screen will be back to the screen, and the reason will be shown in
Alarms Such as the pressure in compressor 1 is beyond the limits. At that time, we
should at first stop the compressor, smooth away the fault, after 10 minutes, press the
reset button, when there is no fault, return to the main menu screen, then operate
2.2 Press UNIT STATE button, the screen will show as figure 4, the working time of
every compressor will be displayed, and the user may determine whether the
5
figure 4
3.1 The user can choose autocontrol button based on the reference。
Press the ON button once, the unit will work, and the screen will show as
OFF and tell you what will do next. If you want to power off , please press the OFF
again.
figure 8
6
4. In the USER SET screen , you can set the temp. of you need.