Professional Documents
Culture Documents
Mechanical Intro 14.5 L02 Basics
Mechanical Intro 14.5 L02 Basics
Поиск по файлам
Go
ا إل ع ال ن ا إل ع ال ن
Yandex
Yandex Games
Games Yandex
Yandex Games
Games
1 2 3 4 5 > >>
Следующая >
L t 2
Lecture 2
Mechanical Basics
Introduction to
ANSYS Mechanic
Chapter Overview
In this chapter we introduce the basic features in Mech
A. Basic Analysis Procedure
B. The Mechanical Interface
C. Menus
D. Toolbars
E. Graphics Control and Selection
F. Outline Tree and Details
G. Tagging and Tree Filtering
H. Graphics Window
I. The Mechanical Application Wizard
J. Scoping Loads and Supports
K. The Engineering Data application
L. Assigning Material Properties
M.Workshop 2-1
2 © 2012 ANSYS, Inc. December 19, 2012
Finite Element Mesh
Toolba
Graphics Window
Outline Tree
Details View
Status Bar
5 © 2012 ANSYS, Inc. December 19, 2012
C. Menus
The View menu:
• Control basic graphics (shaded, wireframe,etc.).
. . . Menus
Annotation Preferences:
• Controls the display of
annotations for
loads/constraints, user
labels, remote conditions
and meshing displays.
. . . Menus
The Units menu:
• Specify the unit system for Mechanical.
• Note, Mechanical may use any unit system
regardless of the one specified in Workbench. Where
needed, automatic conversions will be made.
• Mechanical will “remember” the units used
in the previous session (regardless of the
units set in Workbench).
D. Toolbars
The “Standard” toolbar is shown below (details will be
A
B
C
D
E
1 2 3 4 5 > >>
Следующая >