ISTANBUL MEDIPOL UNIVERSITY
FINE ARTS, DESIGN AND ARCHITECTURE FACULTY
1. Draw each drawing with a scale of 1/5. To rescale, read instructions written in red
2. Meet all requirements of technical drawing rules,
3 Always use papers with title blocks.
4- Draw on milimetric or normal A3 sheets. If the drawing is too large to fit in A3, then draw
the elements which do not fit shorter and use dashed lines to express their contunuity
5- Never draw on tracing paper and any other type of transparent paper.
Paper size: A3 {milimetric/blank paper)
- Its not necessary to draw 3d versions.
You should find the thickness of the all elements and draw the details according to those:
thickness.
- Write all the scale, elements name and thichkness of elements according to technical
= Draw just hand-drawing.
NOTE: Verbatim copying is going to result in FAILING GRADESCEMENT BOARD LAP SIDING - OVER BRICK VENEER
cement board han,
sing
veri a space catyndaion
g2rideton smboad
seating board wih
\Woatherresstn! borer over
\oporretarder where
requted
cov nsvlation to
‘wood tome seo
jaintstoped both
4 floor sy
exactly od wei, 2
7— unfoced coviy rslaton
EXTERIOR
insect mesh to vented
eos vor rtorderrequied
‘gypsum board
Joints toped
cavity insdaion
wood tome.
rin lin. vented or
space
Detail W2 - Cement board lap siding - over brick veneer
$DDetalW2- Cama board ao ting ve brick verBRICK VENEER SIDING - JUNCTION WITH FLOOR/FOUNDATION, ADDITIONAL
INSULATION
extemal ick veer
rmoiture borer on
sheatng boord
Vin. space min for
eae
Detail W10 - Brick veneer siding - junction with floor/foundation - additional insulation
mberwol tame wit,
‘uulaton between
studs
apo retrder whore
required
‘oor wi nslaton
between
sllonchored to concrete
ekw
sllpresue rected o use
moishre barier
protective membrane oho acing