Professional Documents
Culture Documents
AAB 051213 Architecturally Exposed Structural Steel Framing
AAB 051213 Architecturally Exposed Structural Steel Framing
1.0 GENERAL
1.1 DESCRIPTION
This section applies to the finishing system specification to apply to all visible metal
surfaces and members (except stainless steel), as shown in the drawings, and
reference to the Bills of Quantities and contract documents in general.
1.2 STANDARDS
1.3 SUBMITTALS
1.4 PERFORMANCE
2.0 PRODUCTS
1. Paint system finishing coat is to ensure a surface finish that is smooth and
homogenous with only any required and approved texture of the application
such as fine sandpaper or orange- peel, to be visible. The finish is to be such as
an epoxy coat, and final polyurethane coating. The protective coating system
applied prior to this finishing paint system is to comply with Section 051223.
TS/A/SECTION 051213/1
DIVISION 5: METALS
SECTION 051213 ARCHITECTURALLY
EXPOSED STRUCTURAL STEEL FRAMING
2. Paint system colour and gloss content is to be strictly to approval, with the
system to allow for touch-up after installation, such that the appearance of the
adjacent area blends in with the touched-up areas, and with there being no
difference in tone or colour.
3. Prior to the application of at least one initial coat of primer in compliance with the
requirements listed under the performance article, the steel surfaces are to be
prepared strictly according to only the manufacturer’s specifications.
3.0 EXECUTION
1. Application of the paint systems to both visible internal and external metal
members is to be executed in strict compliance only with the manufacturer's
recommendations.
TS/A/SECTION 051213/2